Effect of hydrogen dilution on the structure of SiOF films prepared by remote plasma enhanced chemical vapor deposition from SiF4-based plasmas

2000 ◽  
Vol 18 (6) ◽  
pp. 2827-2834 ◽  
Author(s):  
J. C. Alonso ◽  
E. Pichardo ◽  
V. Pankov ◽  
A. Ortiz
Keyword(s):  
Chemical Vapor Deposition ◽  
Vapor Deposition ◽  
Chemical Vapor ◽  
Remote Plasma ◽  
Hydrogen Dilution

Heteroepitaxial Nucleation and Growth of Ge ON Si(100) Surfaces Using Remote Plasma Enhanced Chemical Vapor Deposition

1988 ◽  
Vol 116 ◽  
Author(s):  
R.A. Rudder ◽  
S.V. Hattangady ◽  
D.J. Vitkavage ◽  
R.J. Markunas
Keyword(s):  
Chemical Vapor Deposition ◽  
Vapor Deposition ◽  
Photoelectron Spectroscopy ◽  
Three Dimensional ◽  
Chemical Vapor ◽  
Layer By Layer ◽  
Heteroepitaxial Growth ◽  
Remote Plasma ◽  
Dimensional Growth ◽  
Diffraction Patterns

Heteroepitaxial growth of Ge on Si(100) has been accomplished using remote plasma enhanced chemical vapor deposition at 300*#x00B0;C. Reconstructed surfaces with diffraction patterns showing non-uniform intensity variations along the lengths of the integral order streaks are observed during the first 100 Å of deposit. This observation of an atomically rough surface during the initial stages of growth is an indication of three-dimensional growth. As the epitaxial growth proceeds, the diffraction patterns become uniform with extensive streaking on both the integral and fractional order streaks. Subsequent growth, therefore, takes place in a layer-by-layer, two-dimensional mode. X-ray photoelectron spectroscopy of the early nucleation stages, less than 80 Å, show that there is uniform coverage with no evidence of island formation.

Bonding of Hydrogen and Deuterium in Silicon Nitride Films Prepared by Remote Plasma Enhanced Chemical Vapor Deposition

1995 ◽  
Vol 377 ◽  
Author(s):  
G. Stevens ◽  
P. Santos-Filho ◽  
S. Habermehl ◽  
G. Lucovsky
Keyword(s):  
Chemical Vapor Deposition ◽  
Vapor Deposition ◽  
Reaction Pathway ◽  
Total Concentration ◽  
Chemical Vapor ◽  
Reaction Model ◽  
Film Deposition ◽  
Growth Surface ◽  
Remote Plasma ◽  
Silicon Nitride Films

ABSTRACTWe have deposited Si-nitride thin films by remote plasma-enhanced chemical-vapor deposition using different combinations of hydrogen and deuterium source gases. In one set of experiments, NH3 and SiH4 were injected downstream from a He plasma and the ratio of NH3 to SiH4 was adjusted so that deposited films contained IR-detectable bonded-H in SiN-H arrangements, but not in Si-H arrangements. Similar results were obtained using the same ND3 to SiD4 flow ratio; these films contained only SiN-D groups. However, films prepared from ND3 and SiH4 displayed both SiN-D and SiN-H groups in essentially equal concentrations establishing that H and D atoms bonded to N are derived from both source gases SiH (D) 4 and NH (D) 3, and further that inter-mixing of H and/or D atoms occurs at the growth surface. This reaction pathway is supported by additional studies in which films were grown from SD4 and ND3 with either i) He or ii) He/H2 mixtures being plasma excited. The films grown from the deuterated source gases without H2, displayed only SiN-D bands, whereas the films grown using the He/H2 mixture displayed both SiN-H and SiN-D bands. The total concentration of N-H and N-D bonds in the films grown from the He/H2 excitation was the same as the concentration of N-D, supporting the surface reaction model. In-situ mass spectrometry provides additional insights in the film deposition reactions.

Sign in / Sign up

Export Citation Format

Share Document