scholarly journals CFD Modeling of Meat and Bone Meal Combustion in a Rotary Cement Kiln

2014 ◽  
Vol 4 (4) ◽  
pp. 263-272 ◽  
Author(s):  
W. K. W. K. Hiromi Ariyaratne ◽  
Anjana Malagalage ◽  
Morten C. Melaaen ◽  
Lars André Tokheim
Keyword(s):  
Cfd Modeling ◽  
Cement Kiln ◽  
Meat And Bone Meal ◽  
Bone Meal ◽  
Rotary Cement Kiln

scholarly journals CFD Modeling of Multi-fuel Combustion of Coal and Meat and Bone Meal (MBM) in a Cement Rotary Kiln

2015 ◽  
Vol 5 (6) ◽  
pp. 353-360 ◽  
Author(s):  
W. K. Hiromi Ariyaratne ◽  
◽  
Morten C. Melaaen ◽  
Lars-André Tokheim
Keyword(s):  
Rotary Kiln ◽  
Fuel Combustion ◽  
Cfd Modeling ◽  
Meat And Bone Meal ◽  
Bone Meal

CFD Simulation of Large Dust Collection Cyclones Positioned Vertically in Staggered Downward Cascade Arrangement

2013 ◽  
Author(s):  
Eugen-Dan Cristea ◽  
Pierangelo Conti
Keyword(s):  
Cfd Simulation ◽  
Solid Phase ◽  
Phase Particle ◽  
High Mass ◽  
Cfd Modeling ◽  
Cement Kiln ◽  
Dust Collection ◽  
Dry Process ◽  
Cascade Arrangement ◽  
Simulation Results

Three dimensional, time dependent Euler-Euler simulation approach for numerical calculation of multiphase strongly swirling turbulent gas-heavy laden particulate flow in large industrial collection cyclones, positioned vertically, in staggered downward cascade arrangement has been performed. The multiphase flow was featured high mass loading. This paper specifically addresses a CFD modeling of a “suspension preheater”, typical equipment for dry process cement kiln. Big sized cyclone separator is a key component of this device. The simulation case study was developed in the frame of the commercial general-purpose code ANSYS-Fluent R13. In cyclone separators the swirling gas motion induces a centrifugal force on the solid particulate phase which is the driving force behind the separation process. The turbulence disperses the solid particulates and enhances the probability that particles are discharged, as reject. Both phenomena are related to solid phase particle size distribution (PSD) and flow pattern into the collection cyclones. The multiphase turbulence was modeled using the RSM Mixture Turbulence Model. The simulation results were validated against industrial measurements carried out on an industrial suspension preheater, in the frame of heat and mass balance of cement kiln energy audit. The numerical simulation results were found in reasonable agreement with the collected industrial measurements. This CFD simulation represents a powerful engineering tool on behalf of the cement process engineer either for new cutting-edge design or for performance verification of an existing plant.

Real-Time PCR Detection of Ruminant DNA

2004 ◽  
Vol 67 (3) ◽  
pp. 550-554 ◽  
Author(s):  
LUIS MENDOZA-ROMERO ◽  
EDWARD L. C. VERKAAR ◽  
PAUL H. SAVELKOUL ◽  
ARNOLD CATSBURG ◽  
HENK J. M. AARTS ◽  
...  
Keyword(s):  
Mitochondrial Dna ◽  
Bovine Spongiform Encephalopathy ◽  
Real Time ◽  
Real Time Pcr ◽  
Spongiform Encephalopathy ◽  
Meat And Bone Meal ◽  
Bone Meal ◽  
Dna Targeting ◽  
Species Origin ◽  
Semiquantitative Method

To control the spread of bovine spongiform encephalopathy, several DNA methods have been described for the detection of the species origin of meat and bone meal. Most of these methods are based on the amplification of a mitochondrial DNA segment. We have developed a semiquantitative method based on real-time PCR for detection of ruminant DNA, targeting an 88-bp segment of the ruminant short interspersed nuclear element Bov-A2. This method is specific for ruminants and is able to detect as little as 10 fg of bovine DNA. Autoclaving decreased the amount of detectable DNA, but positive signals were observed in feeding stuff containing 10% bovine material if this had not been rendered in accordance with the regulations, i.e., heated at 134°C for 3 instead of 20 min.

scholarly journals Bovine meat and Bone Meal as an Economically Viable Alternative in Quail Feeding in the Final Phase

2016 ◽  
Vol 18 (spe) ◽  
pp. 7-12
Author(s):  
CC Pizzolante ◽  
JE Moraes ◽  
SK Kakimoto ◽  
FEL Budiño ◽  
C Móri ◽  
...  
Keyword(s):  
Viable Alternative ◽  
Meat And Bone Meal ◽  
Bone Meal ◽  
Final Phase

scholarly journals Effect of isoproteinous feed on growth and survival of tilapia (Oreochromis niloticus) fry

2012 ◽  
Vol 10 (1) ◽  
pp. 169-174
Author(s):  
I Siddika ◽  
M Das ◽  
K R Sumi
Keyword(s):  
Wheat Flour ◽  
Rice Bran ◽  
Oreochromis Niloticus ◽  
Fish Meal ◽  
Cost Benefit Analysis ◽  
Cost Benefit ◽  
Meat And Bone Meal ◽  
Bone Meal ◽  
Growth And Survival ◽  
Significant Difference

A four week experiment was conducted to evaluate the effect of isoproteinous (35%) feed prepared named diet 1, 2, 3 and 4 respectively by substituting 0%, 50% , 75% and 100% fish meal with meat and bone meal in view of preparing a cost effective tilapia (Oreochromis niloticus) fry feed. The four experimental diets (diet 1 to 4) each were randomly assigned to twelve hapas with three replications. Tilapia fry (0.011g) were randomly stocked in 100 fry/9ft² hapa and fed five times a day up to their apparent satiation. The results of the study showed that the weight gain, specific growth rate (SGR), the apparent net protein utilization value and survival (%) of the fish were significantly  (P<0.05) higher and better feed utilization with lower FCR value was observed in fish fed on the diet 4 where meat and bone meal was used as sole source of protein base. There was no significant difference between the carcass moisture and lipid of fish fed with different experimental diets. The results of the study indicated that diet 1 containing fish meal (45.15% Fish meal, 27.43% Rice bran and 27.43% Wheat flour) can be replaced by meat and bone meal containing diet 4 (54.06% Meat and bone meal, 22.97% Rice bran and 22.97% Wheat flour) with no adverse effects on growth and survival of O. niloticus. Before recommendation several trials will be necessary in different farms to be  sure of the reproducibility of the result obtained in the present experiment. Cost- benefit analysis reveals that the   meat and bone meal containing diet certainly provides cheaper feed.   DOI: http://dx.doi.org/10.3329/jbau.v10i1.12110   J. Bangladesh Agril. Univ. 10(1): 169–174, 2012  

Rotary Cement Kiln Simulator (RoCKS): Integrated modeling of pre-heater, calciner, kiln and clinker cooler

2007 ◽  
Vol 62 (9) ◽  
pp. 2590-2607 ◽  
Author(s):  
Kaustubh S. Mujumdar ◽  
K.V. Ganesh ◽  
Sarita B. Kulkarni ◽  
Vivek V. Ranade
Keyword(s):  
Integrated Modeling ◽  
Cement Kiln ◽  
Rotary Cement Kiln

Response of breeding sows to long term dietary supplementation with folic acid

1994 ◽  
Vol 1994 ◽  
pp. 153-153
Author(s):  
P.B. Lynch ◽  
P.J.A. Sheehy
Keyword(s):  
Folic Acid ◽  
Dietary Supplementation ◽  
Red Cell ◽  
Restricted Feeding ◽  
Meat And Bone Meal ◽  
Bone Meal ◽  
Soyabean Meal ◽  
Dietary Treatments

Dietary supplementation with folic acid has been shown to improve reproductive performance in sows (Lindemann 1993). However most studies have been for one cycle only and few have examined the effect of supplementation over several parities.One hundred and thirty four crossbred sows ranging in parity from 2 to 4 were selected at farrowing and randomly allocated to two dietary treatments of low and high supplemental folic acid (0 and 10 g per tonne, Roche Products Ltd.). Treatments were applied for the following three lactations and post weaning periods, two full pregnancies and to day 30 of the pregnancy following the third lactation. The diet fed contained barley, wheat, soyabean meal and meat and bone meal with nutrient levels of 14.0 MJ DE/kg and 1.02% lysine. Sows were individually penned throughout with restricted feeding in pregnancy (2.2 kg/day increasing to 2.5 kg/day in the final month), and ad libitum in lactation (approx 5.0 kg/day) and post weaning (approx 3.4 kg/day). Blood samples for determination of plasma and red cell folate were taken from 14 sows per treatment on days 4, 50 and 110 of one cycle. These were determined by a microbiological assay (modification of methods of Scott et al 1974 and Wilson and Home 1982).

Sign in / Sign up

Export Citation Format

Share Document