scholarly journals The feasibility of trace element supplementation for stable operation of wheat stillage-fed biogas tank reactors

2011 ◽  
Vol 64 (2) ◽  
pp. 320-325 ◽  
Author(s):  
J. Gustavsson ◽  
B. H. Svensson ◽  
A. Karlsson
Keyword(s):  
Trace Element ◽  
Hydraulic Retention Time ◽  
Loading Rate ◽  
Biogas Production ◽  
Organic Loading Rate ◽  
Stable Operation ◽  
Organic Loading ◽  
Process Stability ◽  
Volatile Solids ◽  
High Sulfate

The aim of this study was to investigate the effect of trace element supplementation on operation of wheat stillage-fed biogas tank reactors. The stillage used was a residue from bio-ethanol production, containing high levels of sulfate. In biogas production, high sulfate content has been associated with poor process stability in terms of low methane production and accumulation of process intermediates. However, the results of the present study show that this problem can be overcome by trace element supplementations. Four lab-scale wheat stillage-fed biogas tank reactors were operated for 345 days at a hydraulic retention time of 20 days (37 °C). It was concluded that daily supplementation with Co (0.5 mg L−1), Ni (0.2 mg L−1) and Fe (0.5 g L−1) were required for maintaining process stability at the organic loading rate of 4.0 g volatile solids L−1 day−1.

scholarly journals Magnetic Biofilm Carriers: The Use of Novel Magnetic Foam Glass Particles in Anaerobic Digestion of Sugar Beet Silage

2014 ◽  
Vol 2014 ◽  
pp. 1-10 ◽  
Author(s):  
Patrice Ramm ◽  
Carsten Jost ◽  
Elisabeth Neitmann ◽  
Ulrich Sohling ◽  
Oliver Menhorn ◽  
...  
Keyword(s):  
Sugar Beet ◽  
Magnetic Particles ◽  
Loading Rate ◽  
Biogas Production ◽  
Foam Glass ◽  
Organic Loading Rate ◽  
Separation Procedure ◽  
Organic Loading ◽  
Magnetic Separator ◽  
Volatile Solids

The use of recently developed magnetic foam glass particles for immobilization of microbial biomass was tested. The effect of the particles was illustrated at the production of biogas from sugar beet silage as the sole substrate. Lab-scale fermentation experiments were conducted using a mesophilic completely stirred tank reactor and a magnetic separator. Microscopic analysis revealed biofilm coverage of 50–60% on the surface of the particles within 110 days. It was possible to recover 76.3% of the particles from fermentation effluent by means of a separation procedure based on magnetic forces. Comparing a particle charged reactor with a control reactor showed a small performance gain. The methane rate was increased from1.18±0.09to1.25±0.06 L L−1 d−1and the methane yield was increased from0.302±0.029to0.318±0.022 L g−1(volatile solids) at an organic loading rate of3.93±0.22 g L−1 d−1(volatile solids). Maximum methane rates of 1.42 L L−1d−1at an organic loading rate of 4.60 g (volatile solids) L−1 d−1(reactor including magnetic particles) and 1.34 L L−1 d−1at 3.73 g L−1 d−1(control reactor) were achieved. Based on the results, it can be concluded that the use of magnetic particles could be an attractive option for the optimization of biogas production.

Enhanced Treatment of CSTR Anaerobic Digested Effluent from Poultry Wastewater by IC Reactor

2012 ◽  
Vol 433-440 ◽  
pp. 1239-1244
Author(s):  
Zhan Guang Liu ◽  
Xue Fei Zhou ◽  
Ya Lei Zhang ◽  
Hong Guang Zhu
Keyword(s):  
Hydraulic Retention Time ◽  
Loading Rate ◽  
Biogas Production ◽  
Granular Sludge ◽  
Anaerobic Treatment ◽  
Controlling Factors ◽  
Organic Loading Rate ◽  
Organic Loading ◽  
Internal Circulation ◽  
Poultry Wastewater

The feasibility of applying internal circulation (IC) reactor anaerobic treatment for effluent from a CSTR plant treating poultry wastewater was examined and the key controlling factors were explored. A continuous-flow IC reactor of 12.3L capacity inoculated with anaerobic granular sludge was operated for 98 days at 35±1°C. With corresponding organic loading rate of 1.5-3.5 kgCOD/m3•d at hydraulic retention time of 1.5d, the maximum volumetric biogas production rate of 1.2 m3/m3•d and tCOD (total COD) removal efficiency in the range of 70-80% was achieved. Therefore, IC reactor is competent to treat CSTR effluent from poultry wastewater. The decrease of sCOD (soluble COD) relative to tCOD and ammonia inhibition may lead to deterioration of IC reactor anaerobic treatment.

Optimization of Hydraulic Retention Time and Organic Loading Rate in Anaerobic Digestion of Squeezed Pineapple Liquid Wastes for Biogas Production

2021 ◽  
Author(s):  
Napisa Pattharaprachayakul ◽  
Narumon Kesonlam ◽  
Pongpitak Duangjumpa ◽  
Vilai Rungsardthong ◽  
Worakrit Suvajittanont ◽  
...  
Keyword(s):  
Anaerobic Digestion ◽  
Retention Time ◽  
Hydraulic Retention Time ◽  
Loading Rate ◽  
Biogas Production ◽  
Solid Wastes ◽  
Organic Loading Rate ◽  
Hybrid Reactor ◽  
Organic Loading ◽  
Liquid Wastes

Pineapple wastes are produced in huge amount during the industrial canning process of pineapple; in Thailand over 400,000 tons per annum of canned pineapple exported leaving behind the waste. Besides the pulps and peels as solid wastes, the squeezed pineapple liquid wastes (SPLW) extracted from solid wastes can also be used for anaerobic digestion. In the present study, the anaerobic digestion of liquid squeezed from industrial pineapple peels was carried out using a lab-scale hybrid reactor. The reactor was operated for over 170 days with the hydraulic retention time (HRT) of 20 days decreasing down to 5 days and simultaneous control of organic loading rate (OLR). Under controlled conditions in the hybrid reactor, pH was maintained at 6.5–7.6 by adding alkaline for anaerobic microbial activity. Results showed that the chemical oxygen demand (COD) removal efficiency was at ≥ 90% for all conditions. The biogas production (mL/day) increased thoroughly from longer HRT to shorter HRT, as same as methane production with the maximum values (HRT 5 days, OLR 5 g/COD/ day with recirculation) of 55,130 and 30,322 mL/day, respectively. Moreover, the highest yields of biogas and methane were also investigated under similar conditions with the values of 0.504 and 0.277 L/gCOD, respectively. Interestingly, this optimization of both HRT and OLR of lab-scale anaerobic digestion process could be further practically applied to pilot or industrial scale in canned pineapple factories for biogas production.

Performance of an anaerobic baffled reactor (ABR) as a hydrolysis-acidogenesis unit in treating landfill leachate mixed with municipal sewage

2000 ◽  
Vol 42 (12) ◽  
pp. 115-121 ◽  
Author(s):  
B. Wang ◽  
Y. Shen
Keyword(s):  
Landfill Leachate ◽  
Loading Rate ◽  
Granular Sludge ◽  
Operational Performance ◽  
Municipal Sewage ◽  
Organic Loading Rate ◽  
Stable Operation ◽  
Organic Loading ◽  
Anaerobic Baffled Reactor ◽  
Biological Treatability

A study on the performance of an Anaerobic Baffled Reactor(ABR) as a hydrolysis-acidogenesis unit in treating the mixed wastewater of landfill leachate and municipal sewage in different volumetric ratios was carried out. The results showed that ABR substantially improved the biological treatability of the mixed wastewater by increasing its BOD5/COD ratio to 0.4–0.6 from the initial values of 0.15–0.3. The formation of bar-shaped granular sludge of 0.5–5 mm both in diameter and length with an SVI of 7.5–14.2 ml/g was observed in all compartments of the ABR when the organic loading rate reached 4.71 kgCOD/m3 · d. The effects of the ratios of NH4+-N/COD and COD/TP in mixed wastewater on the operational performance were also studied, from which it was found that a reasonable NH4+-N/COD ratio should be lower than 0.02, and the phosphorus supplement was needed when the volumetric ratio was higher than 4:6 for stable operation of ABR.

scholarly journals Effect of Hydraulic Retention Time on Biogas Production from Cow Dung in A Semi Continuous Anaerobic Digester

2018 ◽  
Vol 7 (2) ◽  
pp. 93-100 ◽  
Author(s):  
Agus Haryanto ◽  
Sugeng Triyono ◽  
Nugroho Hargo Wicaksono
Keyword(s):  
Retention Time ◽  
Hydraulic Retention Time ◽  
Loading Rate ◽  
Biogas Production ◽  
Stable Condition ◽  
Anaerobic Digester ◽  
Organic Loading Rate ◽  
Cow Dung ◽  
Biogas Yield ◽  
Average Analysis

The efficiency of biogas production in semi-continuous anaerobic digester is influenced by several factors, among other is loading rate. This research aimed at determining the effect of hydraulic retention time (HRT) on the biogas yield. Experiment was conducted using lab scale self-designed anaerobic digester of 36-L capacity with substrate of a mixture of fresh cow dung and water at a ratio of 1:1. Experiment was run with substrate initial amount of 25 L and five treatment variations of HRT, namely 1.31 gVS/L/d (P1), 2.47 gVS/L/d (P2), 3.82 gVS/L/d (P3), 5.35 gVS/L/d (P4) and 6.67 gVS/L/d (P5). Digester performance including pH, temperature, and biogas yield was measured every day. After stable condition was achieved, biogas composition was analyzed using a gas chromatograph. A 10-day moving average analysis of biogas production was performed to compare biogas yield of each treatment. Results showed that digesters run quite well with average pH of 6.8-7.0 and average daily temperature 28.7-29.1. The best biogas productivity (77.32 L/kg VSremoval) was found in P1 treatment (organic loading rate of 1.31 g/L/d) with biogas yield of 7.23 L/d. With methane content of 57.23% treatment P1 also produce the highest methane yield. Biogas production showed a stable rate after the day of 44. Modified Gompertz kinetic equation is suitable to model daily biogas yield as a function of digestion time.Article History: Received March 24th 2018; Received in revised form June 2nd 2018; Accepted June 16th 2018; Available onlineHow to Cite This Article: Haryanto, A., Triyono, S., and Wicaksono, N.H. (2018) Effect of Loading Rate on Biogas Production from Cow Dung in A Semi Continuous Anaerobic Digester. Int. Journal of Renewable Energy Development, 7(2), 93-100.https://doi.org/10.14710/ijred.7.2.93-100

Working Parameters Optimization of Hydrolysis-acidogenesis reactor in two stage anaerobic digestion of slaughterhouse Wastewater for Biogas Production

2020 ◽  
Author(s):  
Dejene Tsegaye Bedane ◽  
Mohammed Mazharuddin Khan ◽  
Seyoum Leta Asfaw
Keyword(s):  
Anaerobic Digestion ◽  
Working Conditions ◽  
Retention Time ◽  
Hydraulic Retention Time ◽  
Loading Rate ◽  
Oxygen Demand ◽  
Organic Loading Rate ◽  
Organic Loading ◽  
Slaughterhouse Wastewater ◽  
Working Parameters

Abstract Background : Wastewater from agro-industries such as slaughterhouse is typical organic wastewater with high value of biochemical oxygen demand, chemical oxygen demand, biological organic nutrients (Nitrogen and phosphate) which are insoluble, slowly biodegradable solids, pathogenic and non-pathogenic bacteria and viruses, parasite eggs. Moreover it contains high protein and putrefies fast leading to environmental pollution problem. This indicates that slaughterhouses are among the most environmental polluting agro-industries. Anaerobic digestion is a sequence of metabolic steps involving consortiums of several microbial populations to form a complex metabolic interaction network resulting in the conversation of organic matter into methane (CH 4 ), carbon dioxide (CO 2 ) and other trace compounds. Separation of the phase permits the optimization of the organic loading rate and HRT based on the requirements of the microbial consortiums of each phase. The purpose of this study was to optimize the working conditions for the hydrolytic - acidogenic stage in two step/phase anaerobic digestion of slaughterhouse wastewater. The setup of the laboratory scale reactor was established at Center for Environmental Science, College of Natural Science with a total volume of 40 liter (36 liter working volume and 4 liter gas space). The working parameters for hydrolytic - acidogenic stage were optimized for six hydraulic retention time 1-6 days and equivalent organic loading rate of 5366.43 – 894.41 mg COD/L day to evaluate the effect of the working parameters on the performance of hydrolytic – acidogenic reactor. Result : The finding revealed that hydraulic retention time of 3 day with organic loading rate of 1,788.81 mg COD/L day was a as an optimal working conditions for the parameters under study for the hydrolytic - acidogenic stage. The degree of hydrolysis and acidification were mainly influenced by lower hydraulic retention time (higher organic loading rate) and highest values recorded were 63.92 % at hydraulic retention time of 3 day and 53.26% at hydraulic retention time of 2 day respectively. Conclusion : The finding of the present study indicated that at steady state the concentration of soluble chemical oxygen demand and total volatile fatty acids increase as hydraulic retention time decreased or organic loading rate increased from 1 day hydraulic retention time to 3 day hydraulic retention time and decreases as hydraulic retention time increase from 4 to 6 day. The lowest concentration of NH 4 + -N and highest degree of acidification was also achieved at hydraulic retention time of 3 day. Therefore, it can be concluded that hydraulic retention time of 3 day/organic loading rate of 1,788.81 mg COD/L .day was selected as an optimal working condition for the high performance and stability during the two stage anaerobic digestion of slaughterhouse wastewater for the hydrolytic-acidogenic stage under mesophilic temperature range selected (37.5℃). Keywords : Slaughterhouse Wastewater, Hydrolytic – Acidogenic, Two Phase Anaerobic Digestion, Optimal Condition, Agro-processing wastewater

Sign in / Sign up

Export Citation Format

Share Document