Influence of Freezing-Thawing Cycles on the Glycemic Index of the Iraqi White Bread after Oral Ingestion

Background: The quality of bread depends not only on the quality of its ingredients, proper techniques during preparation, and storage also played a role in the rate of staling. Aims: The present study aims to investigate the impact of freezing and thawing on the glycemic response of Iraqi local white bread. Methods: In this prospective cross-over study, twelve healthy subjects (seven males, five females), aged 21–53 years, were recruited from Al-Rafidain University Campus and the local community. After overnight fasting, commercial Iraqi local white bread (200 g) was administered as fresh bread, following 1-week or 2-week freezing and thawing. Peak glucose response, 2 hr incremental area under the glucose response curve (AUC0-120) was evaluated as an outcome. Results: The different freezing and thawing conditions resulted in lower blood glucose AUC values compared to fresh white bread. In particular, compared to the fresh bread (AUC 14176±1134 mg min/dl), AUC was significantly lower when the bread was 1-week frozen and thawed (13205±660 mg min/dl, P<0.01), or 2-week frozen and thawed (12828±642 mg min/dl, P<0.01). Meanwhile, compared to the 1-week frozen bread, the 2-week freezing cycle did not produce a significantly lower AUC value. Conclusion: One or two freezing and thawing cycles decreased the glycemic response of the fresh Iraqi local white bread in healthy non-obese volunteers.

Automation of eWeLink Based Fresh Bread Dough System

The process of plain bread dough without sugar after the fermentation process is then left to stand for a certain time manually or modern. The process of developing plain bread dough without sugar can be done by using yeast which is widely sold in the market. The yeast is mixed evenly into the dough, then covered with a cloth and left for a certain time until the dough of plain bread without sugar expands. The factors that influence the development of unsweetened bread dough are the right amount of yeast, temperature and humidity also determine the development process of the bread dough without sugar. If the supporting factors are not suitable, it can cause the plain bread dough without sugar to fail to expand. By using the automation system for bread dough without sugar based on ewelink, it can reduce the failure rate during the development process of bread dough without sugar with optimal results.

Fresh bread to the last piece

The use of technological solutions based on enzyme preparations of maltogenic amylase of the Novamyl® Boost series and Novamyl® 3D BG by Novozymes company allows to prolong the freshness and softness of high-prescription products.

Combined Effect of Chia Flour and Soy Lecithin Incorporation on Nutritional and Technological Quality of Fresh Bread and during Staling

The objectives of the present investigation are to study the interaction and optimize the blend composition of flour of grinded Chia seeds, combined to Soy lecithin, a bread making improver, in a way to enhance the nutritional/functional value of bread without impairing its technological quality and to delay its staling rate. Nine formulations were prepared following a Central Composite Design. Technological attributes were evaluated both for fresh and stored bread. In the Response Surface Methodology (RSM) a desirability function identified the optimum doses of chia and lecithin incorporation to obtain the highest specific volume and the lowest crumb firmness. Compared to the control, samples with chia and lecithin significantly increased the nutritional value of bread. An innovative and interesting synergy was found in lecithin/chia combination to enhance the specific volume, to reduce the initial crumb firmness and to delay bread staling by retarding crumb firmness and reducing its water loss during storage. Using the RSM, the optimum blend containing (4.04%-Chia/1%-Lecithin) showed fresh bread with maximum specific volume and minimum crumb firmness. Whereas, bread combining the optimum blend (3.43%-Chia/1%-Lecithin) and stored for two days at room temperature showed the minimum crumb firmness.

Exposure Assessment to Mycotoxins in a Portuguese Fresh Bread Dough Company by Using a Multi-Biomarker Approach

Mycotoxins are toxic mold metabolites that can persist in environment long after the fungi species responsible for their production disappear. Critical workplace for mycotoxins presence has already been studied and nowadays it is possible to recognize that exposure to mycotoxins through inhalation occurs due to their presence in dust. This study aimed to assess occupational co-exposure to multiple mycotoxins in a fresh bread dough company, an occupational setting not studied until now. Occupational exposure assessment to mycotoxins was done using a LC-MS/MS urinary multi-biomarker approach. Twenty-one workers and nineteen individuals that were used as controls participated in the study. Workers/controls (spot-urine) and environment (settled dust) samples were collected and analyzed. Concerning workers group, DON-GlcA, and OTA were the most prevalent biomarkers (>LOD), 66% and 90.5%, respectively. In the control group, OTA was also one of the most detected (68%) followed by CIT (58%) and DON-GlcA (58%). DON was the mycotoxin measured in high amounts in the settled dust sample (58.2 ng/g). Both workers and controls are exposed to several mycotoxins simultaneously. The workers group, due to their high contact with flour dust, revealed a higher exposure to DON. Considering these results, risk management measures must be applied including specific and adequate health surveillance programs in order to avoid exposure and consequently the associated health consequences.

A new micro-baking method for determination of crumb firmness properties in fresh bread and bread made from frozen dough / Entwicklung eines Mikrobackversuches zur Evaluierung der Krumeneigenschaften von frischen Broten und Broten aus vorgegarten Tiefkühlteiglingen

SummaryIn general, micro-baking tests are used to determine the baking quality when only low amounts of test flour are available, for example, in grain breeding. Several micro-methods are described in literature, but none of them allows the determination of bread crumb texture parameters. Therefore, a micro-baking procedure that offers this option was developed, and it was also evaluated for bread made from pre-fermented frozen doughs. In this procedure, Rapid Visco Analyser (RVA) sample cans were used as baking pans. To examine the capability of this procedure, three wheat flours with different starch properties were chosen. The obtained breads were analyzed with respect to specific loaf volume, crust color and bread crumb firmness. Additionally, a storage test (0-5 days) was performed to determine the crumb firming parameters by kinetics of the Avrami equation. The obtained specific bread volumes revealed significant differences between the flours and the coefficients of variation ranged between 4.2 and 5.5%. Crumb firmness measurement was able to identify significant differences within the samples. The obtained data on firming kinetics reflected the expected properties of samples with different starch properties. Overall, this work demonstrated the feasibility of crumb property measurement on breads on a micro-scale.

Identifikasi Pertumbuhan Jamur Aspergillus Sp pada Roti Tawar yang Dijual di Kota Padang Berdasarkan Suhu dan Lama Penyimpanan

AbstrakPangan yang cukup banyak dikonsumsi masyarakat sebagai makanan kudapan di Indonesia adalah roti tawar. Jamur merupakan mikroorganisme utama yang berperan penting dalam proses pembuatan dan pembusukan roti. Aspergillus merupakan kontaminan umum pada berbagai substrat di daerah tropis maupun subtropik. Tujuan penelitian ini adalah membandingkan pertumbuhan jamur Aspergillus sp yang disimpan pada suhu kamar dan suhu di kulkas. Penelitian ini merupakan penelitian eksperimental analitik. Hasil penelitian menunjukan bahwa pertumbuhan jamur pada suhu kamar lebih cepat dibandingkan suhu kulkas. Pada suhu kamar 25C-28C, jamur Aspergillus sp tumbuh mulai hari ke-3 (33,3%) diikuti pada hari ke-4 (66,7%), sedangkan pada suhu kulkas (10C-15C) mulai tumbuh pada hari ke-5. Temperatur ini juga berhubungan dengan kelembaban relatif karena semakin tinggi suhu maka kelembaban relatif semakin rendah dan sebaliknya, semakin rendah suhu maka kelembaban relatif akan semakin tinggi. Kesimpulan studi ini ialah terdapat perbedaaan pertumbuhan jamur Aspergillus sp yang disimpan pada suhu kamar dan suhu di kulkas walaupun perbedaannya tidak terlalu besar.Kata kunci: roti tawar, aspergillus sp, suhu, lama penyimpanan AbstractThe popular foods consumed by Indonesian citizens is loaves. Fungus is the main microorganism which has the main role in the process of loaves production and decomposition. Aspergillusis the eukaryotes microorganism that has the widest spread in the nature. This worm is also spreading in various substrates in the tropical and sub-tropical areas. The objective of this study was to compare the growth of Aspergillus sp stored in the room temperature and refrigerator temperature This research is analytic experimental. The results of this research showed that the growth of fungus in the room temperature is faster than refrigerator temperature. In the room temperature, the fungus growth starts in the day-3 (33.3%) that is followed by dy-4 (66.7%), while the refrigerator temperature (100C-150C) shows that the fungus growth starts on day-5. The temperature is also related to the Relative Humidity (RH), the higher the temperature, so RH will become lower and vice versa. The foods which store in the low RH will be damaged on the surface side since the fungus, yeast, and certain bacteria. Hence, the fungus on loaves stored in the room temperature will be faster than loaves stored in the refrigerator temperature. There is a difference on the growth of Aspergillus sp stored in the room temperature and refrigerator temperature, even if the difference is not too big.Keywords: fresh bread, aspergillus sp, temperature, prolonged storage