Valorisation of Agricultural Digestate for the Ammonium Sulfate Recovery and Soil Improvers Production

This work investigates an innovative process to valorise agricultural digestate by the exploitation of solar energy. Digestate has been located in a lab-scale greenhouse to evaporate the liquid phase. Digestate vapours, rich in ammonia, are sent in a Drechsler trap, filled with 38% w/w sulfuric acid solution, through three solar air fans. A concentration of about 2 M of ammonium sulphate solution was recovered. The remaining dried solid phase, rich in phosphorous compounds, was evaluated as alternative to the commercial fertilizers (46% P2O5) in the growth of maize plants. Equal amount of P was applied to each pot (25 mg/kg soil). The plants were evaluated along the 8 weeks in a greenhouse monitoring the growth parameters and leaf SPAD index, micro-, macronutrients and non-essential heavy metals. The results evidenced that the dried solid phase of digestate can be used as an alternative source of P. Graphic Abstract

Effect of calcite addition on technical properties and reduction of formaldehyde emissions of medium density fiberboard

Physical, mechanical, and formaldehyde emission properties were studied for medium density fiberboard (MDF) produced with oak (75%) and pine (25%) fibers that had been mechanically refined in the presence of calcite particles. The calcite slurry was prepared at two levels of solids, 1.5% and 3% (10 and 20 kg·m-³). Chips were cooked for 4 min at 185 °C, under 8 bar vapor pressure in an Andritz defibrillator. 1.8% liquid paraffin, 0.72% ammonium sulphate solution, and 11% urea-formaldehyde were added by percentage based on oven-dried wood fibers in the blowline at the exit of the defibrator. The fibers were dried to 11% moisture content. MDF boards (2100 mm × 2800 mm × 18 mm) were created using a continuous hot-press process. The addition of calcite in the course of MDF production resulted in improved physical properties, such as thickness swelling (ThS 24 hours) and water absorption (WA 24 hours). MDF boards prepared with calcite exhibited higher internal bond (IB), modulus of rupture (MOR), and modulus of elasticity (MOE). Resistance to axial withdrawal of screw also was increased by addition of 3% calcite. In addition, the lowest levels of formaldehyde emission were observed for MDF prepared with calcite at the 3% level.

Pilot-Scale Demonstration of Membrane-Based Nitrogen Recovery from Swine Manure

Gas-permeable membranes technology presents a high potential for nitrogen (N) recovery from wastewaters rich in ammonia (NH3). The EU project Ammonia Trapping (AT) is aimed at transferring knowledge from the lab-scale level to on-farm pilot-scale level, using this technology to recover NH3 from livestock wastewaters. The goal of this study is to report the results of an on-farm pilot-scale demonstration plant using gas-permeable membranes to recover N from raw swine manure. After a setup optimization of the plant, stable, and continuous operation was achieved. The maximum NH3 recovery rate obtained was 38.20 g NH3-N m−2 membrane day−1. This recovery rate was greatly affected by the temperature of the process. In addition to its contribution to NH3 emissions reduction, this technology contributes to the recovery of nutrients in the form of a concentrated stable ammonium sulphate solution. This solution contained 3.2% of N, which makes it suitable for fertigation. The economic approach revealed an economic feasibility of the technology, resulting in a cost of 2.07 € per kg N recovered.

Cryoprotection effectiveness of low concentrations of natural and lyophilized LDL (low density lipoproteins) on canine spermatozoa

The aim of this study was to evaluate the use of low concentrations of natural and lyophilized low density lipoprotein (LDL) from hen's egg yolk for cryopreservation of canine semen. Different ammonium sulphate concentrations were tested to extract LDL from egg yolk. The yolk was centrifuged, and LDL was isolated using 10, 20, 40, 45, or 50% ammonium sulphate solution (ASS). The LDL-rich floating fraction was collected for chemical characterization. Dry matter content was lowest (P<0.05) in the LDL extracted with the 50% ASS. The purification of LDL increased in association with increasing ammonium sulphate concentrations. SDS-PAGE showed that the 50% ASS solution yielded a purer fraction of LDL from egg yolk. For semen cryopreservation, TRIS extender was used replacing 20% egg yolk (control) by natural or lyophilized LDL using 1, 2, and 3% (w/v). Semen was centrifuged (755Xg for 7 min), diluted with one of the extenders, packed into 0.5mL straws (100x106 sperm/mL), and placed in a programmable cryopreservation machine. Thawed semen (37°C/ 30s) was analyzed for sperm motility, morphology, and by the hypoosmotic and epifluorescence tests (CFDA/ PI). Natural LDL extracted with 50% ASS was as effective as whole egg yolk to preserve canine frozen sperm when using low concentrations. The lyophilized LDL, mainly in the two higher concentrations tested (2 and 3%), was unsuitable to maintain the effectiveness of the LDL cryoprotective effect on dog sperm.

Sulphur-33 nuclear magnetic resonance spectroscopy of sulphones

The sulphur-33 nmr spectra of 28 sulphones were measured in deuterochloroform solutions at 27.716172 MHz. The spectra were referenced with respect to an external aqueous ammonium sulphate solution and the chemical shifts lay in the range 0 ± 20 ppm, with many lines having a half-height width of less than 200 Hz. Instrumental parameters that affect the spectra were studied. Some of the sulphur-33 resonances can be correlated well with carbon-13 or oxygen-17 resonances in appropriate analogous compounds, and with the Taft σ* parameter.