scholarly journals Aeration to Improve Biogas Production by Recalcitrant Feedstock

Environments ◽  
2019 ◽  
Vol 6 (4) ◽  
pp. 44 ◽  
Author(s):  
John Loughrin ◽  
Nanh Lovanh
Keyword(s):  
Carbon Dioxide ◽  
Anaerobic Digestion ◽  
Methane Production ◽  
Biogas Production ◽  
Day Treatment ◽  
Poultry Litter ◽  
Gas Production ◽  
Quality Degradation ◽  
Small Scales ◽  
Low Levels

Digestion of wastes to produce biogas is complicated by poor degradation of feedstocks. Research has shown that waste digestion can be enhanced by the addition of low levels of aeration without harming the microbes responsible for methane production. This research has been done at small scales and without provision to retain the aeration in the digestate. In this paper, low levels of aeration were provided to poultry litter slurry through a sub-surface manifold that retained air in the sludge. Digestate (133 L) was supplied 0, 200, 800, or 2000 mL/day air in 200 mL increments throughout the day via a manifold with a volume of 380 mL. Digesters were fed 400 g of poultry litter once weekly until day 84 and then 600 g thereafter. Aeration at 200 and 800 mL/day increased biogas production by 14 and 73% compared to anaerobic digestion while aeration at 2000 mL/day decreased biogas production by 19%. Biogas quality was similar in all digesters albeit carbon dioxide and methane were lowest in the 2000 mL/day treatment. Increasing feed to 600 g/week decreased gas production without affecting biogas quality. Degradation of wood disks placed within the digesters was enhanced by aeration.

Study of Methane Production by High Temperature Anaerobic Fermentation of Chicken Manure and Stalks

2020 ◽  
Vol 14 (4) ◽  
pp. 551-557
Author(s):  
Yongku Li ◽  
Xiaomin Hu ◽  
Lei Feng
Keyword(s):  
High Temperature ◽  
Anaerobic Digestion ◽  
Production Rate ◽  
Methane Production ◽  
Anaerobic Fermentation ◽  
Biogas Production ◽  
Gas Production ◽  
Chicken Manure ◽  
Biogas Slurry ◽  
Production Rates

The changing parameters, as the biogas production rate, the methane production rate, the cumulative biogas amount, the cumulative methane amount, the biogas composition, pH etc. in high temperature anaerobic fermentation of chicken manure and stalks were analyzed by experiments with different mass ratios of chicken manure or livestock manure and stalks with a high C/N ratio. The methane production mechanism of high temperature anaerobic digestion of chicken manure and stalks was discussed in detail. It showed that not only the biogas production rates but also the methane production rates of R1–R7 demonstrated the trend of initial increase and then decrease after 50 d of high temperature anaerobic digestion. Besides, the gas production of R1 with pure chicken manure stopped on the 30th d of the reaction. The gas production of other groups R2–R7 also stopped on the corresponding 34th, 36th, 36th, 37th, 37th, and 37th day, respectively. At the end of the reaction, the cumulative biogas amounts and the cumulative methane amounts of R1–R7 were 411.58 and 269.54, 459.91 and 314.41, 425.32 and 294.11, 401.85 and 272.54, 382.63 and 257.07, 363.04 and 218.16, and 257.15 and 160.10 N ml/(g VS). The biogas slurry pH of R1–R7 all demonstrated a trend of initial decrease and then increase, e. g., pH of R2 reached the minimum of 5.94 on the 5th day. pH values of other groups were between 6.01 and 6.39. After the addition of 4 g of sodium bicarbonate on the 7th day, biogas slurry pH of R1–R7 all increased. pH was maintained between 7.16 and 7.44 until the end of the reaction.

scholarly journals Effect of different inoculations on biogas and methane production through anaerobia biodigeston using residues from the avícola sector

2021 ◽  
Vol 42 ◽  
pp. e52
Author(s):  
Joseane Bortolini ◽  
Maria Hermínia Ferreira Tavares ◽  
Ana Claudia Guedes Silva ◽  
Dayane Taine Freitag ◽  
Leandro Fleck ◽  
...  
Keyword(s):  
Anaerobic Digestion ◽  
Methane Production ◽  
Biogas Production ◽  
Poultry Litter ◽  
Organic Load ◽  
Average Percentage ◽  
Volatile Solids ◽  
Main Plot ◽  
Total Average ◽  
Plot Design

The present study aimed to analyze the use of different digestates as inocula for the anaerobic digestion of poultry litter, evaluating the biogas and methane production. The inocula used were: bovine and porcine biofertilizer; with feeding loads of 0.67, 1.00 and 1.67 gVS L-1 day-1. Statistical analyses followed a split-plot design, where the main plot being inoculum and the feeding load as secondary. The experimental data were submitted to analysis of variance, at the level of 5% of significance. The following variable responses were considered: biogas production, specific biogas production as a function of volatile solids (VS) added to the biodigester, specific biogas production as a function of organic load, in terms of COD, and methane production. The highest rates of average biogas production, specific biogas production by VS added, specific production of biogas as a function of COD, and average methane production occurred with the use of bovine inoculum. Through the analysis of the total average percentage of methane production, productions of 63.0% and 54.5% for bovine and swine inoculum. Considering the results obtained, the use of bovine inoculum for the process of anaerobic digestion of poultry litter is recommended vinculado a produção de biogás e metano.

scholarly journals Effect of different inoculations on biogas and methane production through anaerobia biodigeston using residues from the avícola sector

2020 ◽  
Vol 42 ◽  
pp. e73
Author(s):  
Joseane Bortolini ◽  
Ana Claudia Guedes Silva ◽  
Maria Hermínia Ferreira Tavares ◽  
Dayane Taine Freitag ◽  
Leandro Fleck ◽  
...  
Keyword(s):  
Anaerobic Digestion ◽  
Methane Production ◽  
Biogas Production ◽  
Poultry Litter ◽  
Organic Load ◽  
Average Percentage ◽  
Volatile Solids ◽  
Main Plot ◽  
Total Average ◽  
Plot Design

The present study aimed to analyze the use of different digestates as inocula for the anaerobic digestion of poultry litter, evaluating the biogas and methane production. The inocula used were: bovine and porcine biofertilizer; with feeding loads of 0.67, 1.00 and 1.67 gVS L-1 day-1. Statistical analyses followed a split-plot design, where the main plot being inoculum and the feeding load as secondary. The experimental data were submitted to analysis of variance, at the level of 5% of significance. The following variable responses were considered: biogas production, specific biogas production as a function of volatile solids (VS) added to the biodigester, specific biogas production as a function of organic load, in terms of COD, and methane production. The highest rates of average biogas production, specific biogas production by VS added, specific production of biogas as a function of COD, and average methane production occurred with the use of bovine inoculum. Through the analysis of the total average percentage of methane production, productions of 63.0% and 54.5% for bovine and swine inoculum. Considering the results obtained, the use of bovine inoculum for the process of anaerobic digestion of poultry litter is recommended vinculado a produção de biogás e metano.

Leaching and anaerobic digestion of poultry litter for biogas production and nutrient transformation

2019 ◽  
Vol 84 ◽  
pp. 413-422 ◽  
Author(s):  
Kristin Chaump ◽  
Matthew Preisser ◽  
Saravanan R. Shanmugam ◽  
Rishi Prasad ◽  
Sushil Adhikari ◽  
...  
Keyword(s):  
Anaerobic Digestion ◽  
Biogas Production ◽  
Poultry Litter

scholarly journals Pretreatment of Animal Manure Biomass to Improve Biogas Production: A Review

Energies ◽  
2020 ◽  
Vol 13 (14) ◽  
pp. 3573 ◽  
Author(s):  
Meneses-Quelal Orlando ◽  
Velázquez-Martí Borja
Keyword(s):  
Anaerobic Digestion ◽  
Methane Production ◽  
Biogas Production ◽  
Poultry Manure ◽  
Animal Manure ◽  
Methane Yield ◽  
Operational Parameters ◽  
Advantages And Disadvantages ◽  
Physical Chemical ◽  
Chemical Pretreatments

The objective of this research is to present a review of the current technologies and pretreatments used in the fermentation of cow, pig and poultry manure. Pretreatment techniques were classified into physical, chemical, physicochemical, and biological groups. Various aspects of these different pretreatment approaches are discussed in this review. The advantages and disadvantages of its applicability are highlighted since the effects of pretreatments are complex and generally depend on the characteristics of the animal manure and the operational parameters. Biological pretreatments were shown to improve methane production from animal manure by 74%, chemical pretreatments by 45%, heat pretreatments by 41% and physical pretreatments by 30%. In general, pretreatments improve anaerobic digestion of the lignocellulosic content of animal manure and, therefore, increase methane yield.

scholarly journals Evaluation on the Methane Production Potential of Wood Waste Pretreated with NaOH and Co-Digested with Pig Manure

Catalysts ◽  
2019 ◽  
Vol 9 (6) ◽  
pp. 539 ◽  
Author(s):  
Renfei Li ◽  
Wenbing Tan ◽  
Xinyu Zhao ◽  
Qiuling Dang ◽  
Qidao Song ◽  
...  
Keyword(s):  
Anaerobic Digestion ◽  
Lignocellulosic Biomass ◽  
Methane Production ◽  
Biogas Production ◽  
Untreated Wood ◽  
Wood Waste ◽  
Methane Yield ◽  
Pig Manure ◽  
Naoh Pretreatment ◽  
Digestion Technique

Wood waste generated during the tree felling and processing is a rich, green, and renewable lignocellulosic biomass. However, an effective method to apply wood waste in anaerobic digestion is lacking. The high carbon to nitrogen (C/N) ratio and rich lignin content of wood waste are the major limiting factors for high biogas production. NaOH pre-treatment for lignocellulosic biomass is a promising approach to weaken the adverse effect of complex crystalline cellulosic structure on biogas production in anaerobic digestion, and the synergistic integration of lignocellulosic biomass with low C/N ratio biomass in anaerobic digestion is a logical option to balance the excessive C/N ratio. Here, we assessed the improvement of methane production of wood waste in anaerobic digestion by NaOH pretreatment, co-digestion technique, and their combination. The results showed that the methane yield of the single digestion of wood waste was increased by 38.5% after NaOH pretreatment compared with the untreated wood waste. The methane production of the co-digestion of wood waste and pig manure was higher than that of the single digestion of wood waste and had nonsignificant difference with the single-digestion of pig manure. The methane yield of the co-digestion of wood waste pretreated with NaOH and pig manure was increased by 75.8% than that of the untreated wood waste. The findings indicated that wood waste as a sustainable biomass source has considerable potential to achieve high biogas production in anaerobic digestion.

scholarly journals Narasin as a Manure Additive to Reduce Methane Production from Swine Manure

2018 ◽  
Vol 61 (3) ◽  
pp. 943-953
Author(s):  
Daniel S. Andersen ◽  
Fan Yang ◽  
Steven L. Trabue ◽  
Brian J. Kerr ◽  
Adina Howe
Keyword(s):  
Methane Production ◽  
Biogas Production ◽  
Safety Concern ◽  
Swine Manure ◽  
Inhibitory Effect ◽  
Gas Production ◽  
Dose Rates ◽  
Deep Pit ◽  
Sugar Addition ◽  
Swine Operations

Abstract. High levels of methane production from swine operations have been associated with foam accumulation in deep-pit manure storage systems. This foam poses both a safety concern (i.e., flash fires) and operational challenges in managing stored manure. Mitigating methane production is one approach to controlling foam accumulation. In this study, swine manures obtained from three deep-pit storage barns in central Iowa were dosed with narasin to evaluate its inhibitory effects on methane and biogas production. Dose rates ranged from 0 to 3.0 mg narasin kg-1 manure. Overall, methane rates were reduced by 9% for each mg of narasin added per kg of manure, and this reduction was effective for up to 25 days. However, the inhibitory effect weakened with time such that no statistical difference in cumulative methane production between samples dosed with narasin and undosed controls could be detected after 120 days of incubation. In addition to methane rates, narasin addition reduced the degradation of total and volatile solids in the manure by 1.9% and 2.6%, respectively, for each mg of narasin added per kg of manure. Additional study treatments included sugar (10 g kg-1 manure) with and without narasin (1.5 mg narasin kg-1 manure). Results from this treatment showed that methane production was initially increased by the sugar addition, but the effect lasted less than six days, at which point cumulative methane production was similar to the control. When treated with both narasin and sugar, the inhibitory effect did not impact gas production during the sugar digestion phase but did reduce methane and biogas production thereafter. The addition of sugar and the rate of narasin addition caused changes to the microbial community as compared to the control. Overall, the results indicated that narasin can be an effective additive for reducing methane emission from swine manure, but further study is needed to recommend dosing frequency and to evaluate how continuous addition of manure impacts narasin effectiveness. Keywords: Biogas, Manure management, Manure treatment, Methane, Narasin, Swine manure, Swine production.

scholarly journals Enhancement anaerobic digestion and methane production from kitchen waste by thermal and thermo-chemical pretreatments in batch  leach bed reactor with down flow

2018 ◽  
Vol 64 (No. 3) ◽  
pp. 128-135 ◽  
Author(s):  
Radmard Seyed Abbas ◽  
Alizadeh Hossein Haji Agha ◽  
Seifi Rahman
Keyword(s):  
Anaerobic Digestion ◽  
Microwave Irradiation ◽  
Methane Production ◽  
Biogas Production ◽  
Oxygen Demand ◽  
Lag Phase ◽  
Kitchen Waste ◽  
Gompertz Equation ◽  
Chemical Pretreatments ◽  
Pretreatment Conditions

The effects of thermal (autoclave and microwave irradiation (MW)) and thermo-chemical (autoclave and microwave irradiation – assisted NaOH 5N) pretreatments on the chemical oxygen demand (COD) solubilisation, biogas and methane production of anaerobic digestion kitchen waste (KW) were investigated in this study. The modified Gompertz equation was fitted to accurately assess and compare the biogas and methane production from KW under the different pretreatment conditions and to attain representative simulations and predictions. In present study, COD solubilisation was demonstrated as an effective effect of pretreatment. Thermo-chemical pretreatments could improve biogas and methane production yields from KW. A comprehensive evaluation indicated that the thermo-chemical pretreatments (microwave irradiation and autoclave- assisted NaOH 5N, respectively) provided the best conditions to increase biogas and methane production from KW. The most effective enhancement of biogas and methane production (68.37 and 36.92 l, respectively) was observed from MW pretreated KW along with NaOH 5N, with the shortest lag phase of 1.79  day, the max. rate of 2.38 l·day<sup>–1</sup> and ultimate biogas production of 69.8 l as the modified Gompertz equation predicted.

Effect of a Cellulose-Degrading Strain on Anaerobic Fermentation of Corn Straw

2011 ◽  
Vol 356-360 ◽  
pp. 2510-2514 ◽  
Author(s):  
Ming Fen Niu ◽  
Sai Yue Wang ◽  
Wen Di Xu ◽  
An Dong Ge ◽  
Hao Wang
Keyword(s):  
Fatty Acids ◽  
Anaerobic Digestion ◽  
Methane Production ◽  
Volatile Fatty Acids ◽  
Anaerobic Fermentation ◽  
Biogas Production ◽  
Corn Straw ◽  
High Efficient ◽  
Important Significance ◽  
Strong Capacity

In order to improve the rate of degradation of cellulose in corn straw, the study has an important significance that compost corn straw with inoculating high-efficient microbe agents. The experiment inoculated a cellulose-degrading strain F2 which was screened from compost into compost pretreatment, the VS of corn straw reduced from 93.14% to 71.69% after 15 days, the content of cellulose reduced from 34.12g·kg-1 to 25.66g·kg-1, the rate of degradation was 24.79% which was 10.60% higher than those without the strain. An anaerobic fermentation experiment was carried out with the two groups of composted corn straw and mixed pig feces with a certain ratio, and investigations of biogas production, pH, content of volatile fatty acids(VFA) and rate of methane production were conducted. The results were that the corn straw composted with the cellulose-degrading strain peaked 4 days earlier, the maximal daily biogas production was 1470mL, the cumulative biogas production reached 23641mL which was 16.87% higher and operated stably earlier. The study showed that the cellulose-degrading strain had a strong capacity to degrade cellulose in corn straw, and then improved the performance of anaerobic digestion.

Solid-State Anaerobic Digestion for Methane Production from Corn Stalks with Stack-Pretreated

2011 ◽  
Vol 697-698 ◽  
pp. 326-330 ◽  
Author(s):  
S.X. Zhou ◽  
Y.P. Dong ◽  
Y.L. Zhang
Keyword(s):  
Anaerobic Digestion ◽  
Solid State ◽  
Methane Production ◽  
Biogas Production ◽  
Cow Dung ◽  
Cow Manure ◽  
Pretreatment Method ◽  
Biogas Yield ◽  
Microbial Pretreatment ◽  
Microbial Strains

Microbial pretreatment was applied to enhance biogas production from corn stover through solid-state anaerobic digestion, but the price of microbial strains is high. The objective of this study was to find the effects on biogas production by the naturally microbial pretreatment method. The highest cumulative biogas yield for 60-day solid-state anaerobic digestion was obtained in B group (the pretreated corn straws with cow dung), which was 19.6% higher than that of the untreated samples. The D group（the pretreated corn straws with the sludge）cumulative biogas yield for 60-day solid-state anaerobic digestion was obtained, which was 18.87% higher than that of the untreted samples. The biogas of D group increased to the range of 55%～60% methane content, while B group with the range of 75%～80%.The results indicated that the pretreated corn straws mixing cow manure can improve both the biogas production yield and the content of methane in CH4。

Sign in / Sign up

Export Citation Format

Share Document