Effect of sodium salt on anaerobic digestion of kitchen waste

2016 ◽  
Vol 73 (8) ◽  
pp. 1865-1871 ◽  
Author(s):  
Naveed Anwar ◽  
Wen Wang ◽  
Jie Zhang ◽  
Yeqing Li ◽  
Chang Chen ◽  
...  
Keyword(s):  
Anaerobic Digestion ◽  
Sodium Salt ◽  
Salt Concentration ◽  
Methane Production ◽  
Volatile Fatty Acids ◽  
Production Performance ◽  
Methane Yield ◽  
Production Model ◽  
Lag Phase ◽  
Kitchen Waste

The effect of different sodium salt concentration on anaerobic digestion of kitchen waste was investigated. The methane production performance, the corresponding methane production model and sodium salt inhibition model were studied, and the degradation efficiency was analyzed. With the increase of sodium salt concentration, the methane yield and the maximal methane production rate decreased along with the increase of lag phase time. The highest methane yield of 594 mL/g-VSadded (VS: volatile solids) was found with no sodium salt addition while the lowest was obtained with addition of 16 g/L NaCl. The declines of the methane yield were negligible when the sodium salt concentration was below 8 g/L, which corresponded to <10% inhibiting efficiency. In contrast, a sharp decrease of methane yield was observed with addition of >8 g/L NaCl (causing 17–80% inhibition). Five kinds of regression models were developed to describe the sodium salt inhibition efficiency, and the cubic regression model of y = 0.508 + 2.401x − 0.369x2 + 0.033x3 showed the best fitting. The volatile fatty acids/ethanol gradually accumulated along with the increase of the sodium salt concentration, and the volatile solid removal efficiency represented a gradual decline accordingly. It is recommended that the sodium salt concentration in the anaerobic digesters should be controlled below 8 g/L in order to avoid intense methane inhibition.

Temperature effects on the trophic stages of perennial rye grass anaerobic digestion

2011 ◽  
Vol 64 (1) ◽  
pp. 70-76 ◽  
Author(s):  
D. Cysneiros ◽  
A. Thuillier ◽  
R. Villemont ◽  
A. Littlestone ◽  
T. Mahony ◽  
...  
Keyword(s):  
Anaerobic Digestion ◽  
Low Temperature ◽  
Methane Production ◽  
Volatile Fatty Acids ◽  
Oxygen Demand ◽  
Production Performance ◽  
Batch Mode ◽  
Rye Grass ◽  
Long Term Experiment ◽  
Rate Limiting

Continuous Stirred Tank Reactors (CSTRs), operated in batch mode, were used to evaluate the feasibility of psychrophilic (low temperature) digestion of perennial rye grass in a long term experiment (150 days) for the first time. The reactors were operated in parallel at 3 different temperatures, 10, 15 and 37 °C. Hydrolysis, acidification and methanogenesis were assessed by VS degradation, by soluble chemical oxygen demand (SCOD) and volatile fatty acids (VFA) production, and by methane production, respectively. Hydrolysis was the rate-limiting step at all temperatures and the rates and extent of hydrolysis were considerably lower at 15 and 10 °C, than at 37 °C. The total VS degradation was 53%, 34% and 19% at 37, 15 and 10 °C, respectively. Acidification was not affected by temperature and VFA production and consumption was balanced in all cases, except at 10 °C. Methane yields were 0.215 m3 CH4 kg−1 VS−1 added, 0.160 m3 CH4 kg−1 VS−1 added and 0.125 m3 CH4 kg−1 VS−1 added at 37, 15 and 10 °C, respectively. Methanogenesis was not strongly affected at 15 °C but it became rate-limiting at 10 °C. Overall, the solid degradation and methane production performance under psychrophilic conditions was encouraging and greater than previously reported. Considering the non-acclimated, mesophilic nature of the inoculum, there are grounds to believe that low-temperature anaerobic digestion of grass could be feasible if coupled to efficient hydrolysis of the biomass.

scholarly journals Enhancement anaerobic digestion and methane production from kitchen waste by thermal and thermo-chemical pretreatments in batch  leach bed reactor with down flow

2018 ◽  
Vol 64 (No. 3) ◽  
pp. 128-135 ◽  
Author(s):  
Radmard Seyed Abbas ◽  
Alizadeh Hossein Haji Agha ◽  
Seifi Rahman
Keyword(s):  
Anaerobic Digestion ◽  
Microwave Irradiation ◽  
Methane Production ◽  
Biogas Production ◽  
Oxygen Demand ◽  
Lag Phase ◽  
Kitchen Waste ◽  
Gompertz Equation ◽  
Chemical Pretreatments ◽  
Pretreatment Conditions

The effects of thermal (autoclave and microwave irradiation (MW)) and thermo-chemical (autoclave and microwave irradiation – assisted NaOH 5N) pretreatments on the chemical oxygen demand (COD) solubilisation, biogas and methane production of anaerobic digestion kitchen waste (KW) were investigated in this study. The modified Gompertz equation was fitted to accurately assess and compare the biogas and methane production from KW under the different pretreatment conditions and to attain representative simulations and predictions. In present study, COD solubilisation was demonstrated as an effective effect of pretreatment. Thermo-chemical pretreatments could improve biogas and methane production yields from KW. A comprehensive evaluation indicated that the thermo-chemical pretreatments (microwave irradiation and autoclave- assisted NaOH 5N, respectively) provided the best conditions to increase biogas and methane production from KW. The most effective enhancement of biogas and methane production (68.37 and 36.92 l, respectively) was observed from MW pretreated KW along with NaOH 5N, with the shortest lag phase of 1.79  day, the max. rate of 2.38 l·day<sup>–1</sup> and ultimate biogas production of 69.8 l as the modified Gompertz equation predicted.

Study on Solid-State Anaerobic Co-Digestion with Distiller’s Grains and Food Waste for Methane Production

2012 ◽  
Vol 485 ◽  
pp. 306-309
Author(s):  
Li Hong Wang ◽  
Qun Hui Wang ◽  
Wei Wei Cai
Keyword(s):  
Anaerobic Digestion ◽  
Solid State ◽  
Synergistic Effect ◽  
Food Waste ◽  
Methane Production ◽  
Waste Treatment ◽  
Biogas Production ◽  
Methane Yield ◽  
Kitchen Waste ◽  
Distiller's Grains

Solid-state anaerobic digestion (SSAD) of distiller’s grains (DG) and kitchen waste (KW) for biogas was investigated. Six DG to KW ratios of 10/1, 8/1, 6/1, 4/1, 1/0, and 0/1 was used. The results showed that in 48 digestion days the co-digestion with DG to KW ratio of 8:1 obtained the highest methane yield of 159.74mL/gTS, TS and VS reductions of 58.7% and 71.8%, hemicellulase, cellulose and lignin reductions of 46.7%, 45.4% and 4.0%. Compared to mono-digestions of DG or KW, co-digestion of DG and FW had a good synergistic effect. It indicated that SSAD of cellulosic-based waste and food waste could be one of the options for efficient biogas production and waste treatment

scholarly journals Enhancing methane production from the invasive macroalga Rugulopteryx okamurae through anaerobic co-digestion with olive mill solid waste: process performance and kinetic analysis

2021 ◽  
Author(s):  
D. de la Lama-Calvente ◽  
M. J. Fernández-Rodríguez ◽  
J. Llanos ◽  
J. M. Mancilla-Leytón ◽  
R. Borja
Keyword(s):  
Anaerobic Digestion ◽  
Solid Waste ◽  
Methane Production ◽  
Methane Yield ◽  
Specific Rate ◽  
Order Kinetic ◽  
Two Phase ◽  
First Order ◽  
Olive Mill Solid Waste ◽  
Olive Mill

AbstractThe biomass valorisation of the invasive brown alga Rugulopteryx okamurae (Dictyotales, Phaeophyceae) is key to curbing the expansion of this invasive macroalga which is generating tonnes of biomass on southern Spain beaches. As a feasible alternative for the biomass management, anaerobic co-digestion is proposed in this study. Although the anaerobic digestion of macroalgae barely produced 177 mL of CH4 g−1 VS, the co-digestion with a C-rich substrate, such as the olive mill solid waste (OMSW, the main waste derived from the two-phase olive oil manufacturing process), improved the anaerobic digestion process. The mixture improved not only the methane yield, but also its biodegradability. The highest biodegradability was found in the mixture 1 R. okamurae—1 OMSW, which improved the biodegradability of the macroalgae by 12.9% and 38.1% for the OMSW. The highest methane yield was observed for the mixture 1 R. okamurae—3 OMSW, improving the methane production of macroalgae alone by 157% and the OMSW methane production by 8.6%. Two mathematical models were used to fit the experimental data of methane production time with the aim of assessing the processes and obtaining the kinetic constants of the anaerobic co-digestion of different combination of R. okamurae and OMSW and both substrates independently. First-order kinetic and the transference function models allowed for appropriately fitting the experimental results of methane production with digestion time. The specific rate constant, k (first-order model) for the mixture 1 R. okamurae- 1.5 OMSW, was 5.1 and 1.3 times higher than that obtained for the mono-digestion of single OMSW and the macroalga, respectively. In the same way, the transference function model revealed that the maximum methane production rate (Rmax) was also found for the mixture 1 R. okamurae—1.5 OMSW (30.4 mL CH4 g−1 VS day−1), which was 1.6 and 2.2 times higher than the corresponding to the mono-digestions of the single OMSW and sole R. okamurae (18.9 and 13.6 mL CH4 g−1 VS day−1), respectively.

Sludge accumulation and methanogenic activity in an anaerobic lagoon

2000 ◽  
Vol 42 (10-11) ◽  
pp. 247-255 ◽  
Author(s):  
J. Paing ◽  
B. Picot ◽  
J. P. Sambuco ◽  
A. Rambaud
Keyword(s):  
Anaerobic Digestion ◽  
Methane Production ◽  
Anaerobic Degradation ◽  
Volatile Fatty Acids ◽  
Anaerobic Fermentation ◽  
Methanogenic Activity ◽  
Start Up ◽  
Anaerobic Lagoon ◽  
Methane Production Rate ◽  
Sludge Accumulation

Sludge accumulation and the characteristics of anaerobic digestion in sludge had been investigated in a primary anaerobic lagoon. Methanogenic potential of sludge was evaluated by an anaerobic digestion test which measured the methane production rate. Sludge was sampled at several points in the lagoon to determine spatial variations and with a monthly frequency from the start-up of the lagoon to observe the development of anaerobic degradation. Maximum amounts of sludge accumulated near the inlet. The mean methane production of sludge was 2.9 ml gVS–1 d–1. Sludge near the outlet presented a greater methanogenic activity and a lesser concentration of volatile fatty acids than near the inlet. The different stages of anaerobic degradation were spatially separated, acidogenesis near the inlet and methanogenesis near the outlet. This staged distribution seemed to increase efficiency of anaerobic fermentation compared with septic tanks. Methane release at the surface of the lagoon was estimated to be very heterogeneous with a mean of 25 l m–2 d–1. The development of performance and sludge characteristics showed the rapid beginning of methanogenesis, three months after the start-up of the anaerobic lagoon. Considering the volume of accumulated sludge, it could however be expected that methanogenic activity would further increase.

scholarly journals Effects of sulfonamide antibiotics on digestion performance and microbial community during swine manure anaerobic digestion

2020 ◽  
Vol 26 (1) ◽  
Author(s):  
Shaona Wang ◽  
Kang Du ◽  
Rongfang Yuan ◽  
Huilun Chen ◽  
Fei Wang ◽  
...  
Keyword(s):  
Organic Matter ◽  
Anaerobic Digestion ◽  
Dissolved Organic Matter ◽  
Methane Production ◽  
Volatile Fatty Acids ◽  
High Throughput Sequencing ◽  
Batch Reactor ◽  
Inhibition Mechanism ◽  
Sulfonamide Antibiotics ◽  
High Concentration

The effects of four types of sulfonamide antibiotics (SAs), including sulfaquinoxaline, sulfamethoxazole, sulfamethoxydiazine and sulfathiazole, on the digestion performance during anaerobic digestion process were studied using a lab-scale anaerobic sequencing batch reactor, and the changes of the community structure in the presence of SAs were investigated with the help of high throughput sequencing. The results indicated that when SAs were added, the hydrolytic acidification process was inhibited, and the accumulation of volatile fatty acids (VFAs) was induced, resulting in the suppression of methane production. However, the inhibition mechanism of different SAs was quite different. The inhibitory effect of high concentration of SAs on the hydrolysis of solid particulate matter into dissolved organic matter followed the order of sulfaquinoxaline > sulfamethoxydiazine > sulfathiazole > sulfamethoxazole. SAs have obvious inhibitory effects on acidification and methanation of dissolved organic matter, especially sulfathiazole. The richness and the community composition of the microorganism including bacteria and archaea in the digestion system were affected by SAs. Under the effect of SAs, the relative abundance of many microorganisms is negatively correlated with methane production, among which Methanobrevibacter, a kind of Archaea, had the greatest influence on methane production.

scholarly journals Thermophilic Alkaline Fermentation Followed by Mesophilic Anaerobic Digestion for Efficient Hydrogen and Methane Production from Waste-Activated Sludge: Dynamics of Bacterial Pathogens as Revealed by the Combination of Metagenomic and Quantitative PCR Analyses

2018 ◽  
Vol 84 (6) ◽  
Author(s):  
Jingjing Wan ◽  
Yuhang Jing ◽  
Yue Rao ◽  
Shicheng Zhang ◽  
Gang Luo
Keyword(s):  
Microbial Community ◽  
Anaerobic Digestion ◽  
Activated Sludge ◽  
Quantitative Pcr ◽  
Methane Production ◽  
Bacterial Pathogens ◽  
Methane Yield ◽  
Metagenomic Analysis ◽  
Waste Activated Sludge ◽  
Hydrogen Yield

ABSTRACT Thermophilic alkaline fermentation followed by mesophilic anaerobic digestion (TM) for hydrogen and methane production from waste-activated sludge (WAS) was investigated. The TM process was also compared to a process with mesophilic alkaline fermentation followed by a mesophilic anaerobic digestion (MM) and one-stage mesophilic anaerobic digestion (M) process. The results showed that both hydrogen yield (74.5 ml H 2 /g volatile solids [VS]) and methane yield (150.7 ml CH 4 /g VS) in the TM process were higher than those (6.7 ml H 2 /g VS and 127.8 ml CH 4 /g VS, respectively) in the MM process. The lowest methane yield (101.2 ml CH 4 /g VS) was obtained with the M process. Taxonomic results obtained from metagenomic analysis showed that different microbial community compositions were established in the hydrogen reactors of the TM and MM processes, which also significantly changed the microbial community compositions in the following methane reactors compared to that with the M process. The dynamics of bacterial pathogens were also evaluated. For the TM process, the reduced diversity and total abundance of bacterial pathogens in WAS were observed in the hydrogen reactor and were further reduced in the methane reactor, as revealed by metagenomic analysis. The results also showed not all bacterial pathogens were reduced in the reactors. For example, Collinsella aerofaciens was enriched in the hydrogen reactor, which was also confirmed by quantitative PCR (qPCR) analysis. The study further showed that qPCR was more sensitive for detecting bacterial pathogens than metagenomic analysis. Although there were some differences in the relative abundances of bacterial pathogens calculated by metagenomic and qPCR approaches, both approaches demonstrated that the TM process was more efficient for the removal of bacterial pathogens than the MM and M processes. IMPORTANCE This study developed an efficient process for bioenergy (H 2 and CH 4 ) production from WAS and elucidates the dynamics of bacterial pathogens in the process, which is important for the utilization and safe application of WAS. The study also made an attempt to combine metagenomic and qPCR analyses to reveal the dynamics of bacterial pathogens in anaerobic processes, which could overcome the limitations of each method and provide new insights regarding bacterial pathogens in environmental samples.

Application of Methanobrevibacter acididurans in anaerobic digestion

2004 ◽  
Vol 50 (6) ◽  
pp. 109-114 ◽  
Author(s):  
D.V. Savant ◽  
D.R. Ranade
Keyword(s):  
Fatty Acids ◽  
Anaerobic Digestion ◽  
Methane Production ◽  
Volatile Fatty Acids ◽  
Low Ph ◽  
Anaerobic Digesters ◽  
Hydrogenotrophic Methanogen ◽  
Distillery Wastewater ◽  
Acid Tolerant ◽  
Acidic Conditions

To operate anaerobic digesters successfully under acidic conditions, hydrogen utilizing methanogens which can grow efficiently at low pH and tolerate high volatile fatty acids (VFA) are desirable. An acid tolerant hydrogenotrophic methanogen viz. Methanobrevibacter acididurans isolated from slurry of an anaerobic digester running on alcohol distillery wastewater has been described earlier by this lab. This organism could grow optimally at pH 6.0. In the experiments reported herein, M. acididurans showed better methanogenesis under acidic conditions with high VFA, particularly acetate, than Methanobacterium bryantii, a common hydrogenotrophic inhabitant of anaerobic digesters. Addition of M. acididurans culture to digesting slurry of acidogenic as well as methanogenic digesters running on distillery wastewater showed increase in methane production and decrease in accumulation of volatile fatty acids. The results proved the feasibility of application of M. acididurans in anaerobic digesters.

scholarly journals Pretreatment of Animal Manure Biomass to Improve Biogas Production: A Review

Energies ◽  
2020 ◽  
Vol 13 (14) ◽  
pp. 3573 ◽  
Author(s):  
Meneses-Quelal Orlando ◽  
Velázquez-Martí Borja
Keyword(s):  
Anaerobic Digestion ◽  
Methane Production ◽  
Biogas Production ◽  
Poultry Manure ◽  
Animal Manure ◽  
Methane Yield ◽  
Operational Parameters ◽  
Advantages And Disadvantages ◽  
Physical Chemical ◽  
Chemical Pretreatments

The objective of this research is to present a review of the current technologies and pretreatments used in the fermentation of cow, pig and poultry manure. Pretreatment techniques were classified into physical, chemical, physicochemical, and biological groups. Various aspects of these different pretreatment approaches are discussed in this review. The advantages and disadvantages of its applicability are highlighted since the effects of pretreatments are complex and generally depend on the characteristics of the animal manure and the operational parameters. Biological pretreatments were shown to improve methane production from animal manure by 74%, chemical pretreatments by 45%, heat pretreatments by 41% and physical pretreatments by 30%. In general, pretreatments improve anaerobic digestion of the lignocellulosic content of animal manure and, therefore, increase methane yield.

Sign in / Sign up

Export Citation Format

Share Document