GAC adsorption treated pulp and paper mill effluents using ozone as a pre-treatment

2009 ◽  
Vol 4 (2) ◽  
Author(s):  
T. Kreetachat ◽  
M. Damrongsri ◽  
P. Vaithanomsat
Keyword(s):  
Adsorption Capacity ◽  
Paper Mill ◽  
Pulp And Paper ◽  
Maximum Adsorption Capacity ◽  
Pulp And Paper Mill ◽  
Aliphatic Compounds ◽  
Paper Mill Effluents ◽  
Pre Treatment ◽  
The Impact ◽  
Gac Adsorption

This research examined the impact of ozonation on lignin-derived and aliphatic compounds ratio (L/A ratio) in secondary pulp and paper mill effluents. Afterwards, adsorption process was employed to investigate the adsorption behavior of ozonized compounds on granular activated carbon (GAC). Phenol and isopentanoic acid (IPA) were practically used as substitute of lignin-derived and aliphatic compounds, respectively. The paper presents the results obtained at laboratory scale with ozone and GAC adsorption as a mean to obtain effluents suitable as reclamation for pulp and paper industry, which requires very stringent limitation in terms of DOC and color removal. The conversion of recalcitrant nature of pulp and paper mill wastewater had been moderate in term of L/A ratio after time interval of ozonation. After ozonation pre-treatment, the adsorption experimental was performed to investigate the adsorption behaviors of phenol and IPA from aqueous solutions onto GAC compared with the decolorization behaviors in real effluents. The best isotherm models fitted to phenol and IPA adsorption on PPHO were determined in the order of Ridlich-Peterson isotherm > Langmuir isotherm > Freundlich isotherm. The IPA was adsorbed strongly on GAC as compared with phenol due to its properties. The maximum adsorption capacity of phenol and IPA on GAC were 0.32 g.g-1 and 0.65 g.g-1, respectively. As result in real effluents, the adsorption capacity of color from the ozonized effluents on GAC was 132.93 ADMI unit.L/mg which was much higher than those of non-ozonized effluents (78.78 ADMI unit.L/mg) and synthetic lignin solutions (55.97 ADMI unit.L/mg).

Anaerobic treatment of pulp and paper mill effluents – status quo and new developments

2007 ◽  
Vol 55 (6) ◽  
pp. 223-230 ◽  
Author(s):  
Leo Habets ◽  
Willie Driessen
Keyword(s):  
Paper Industry ◽  
Industrial Effluents ◽  
Paper Mill ◽  
Anaerobic Treatment ◽  
Pulp And Paper ◽  
Pulp And Paper Mill ◽  
Widespread Application ◽  
Paper Mills ◽  
Paper Mill Effluents ◽  
Pre Treatment

Since the early 1980s, anaerobic treatment of industrial effluents has found widespread application in the pulp and paper industry. Over 200 installations are treating a large variety of different pulp and paper mill effluents. Amongst various anaerobic systems the UASB and IC are the most applied anaerobic reactor systems. Anaerobic treatment is well feasible for effluents originated from recycle paper mills, mechanical pulping (peroxide bleached), semi-chemical pulping and sulphite and kraft evaporator condensates. The advantages of anaerobic pre-treatment are (1) net production of renewable energy (biogas), (2) minimized bio-solids production, (3) minimal footprint and (4) reduced emission of greenhouse gases. Via in-line application of anaerobic treatment in closed circuits (paper kidney technology) further savings on cost of fresh water intake and effluent discharge levies are generated.

The Benefits of Biotreatment for Reducing the Effects of Pulp and Paper Mill Effluents on Fish Reproduction in Laboratory Tests

2008 ◽  
Vol 43 (2-3) ◽  
pp. 161-171 ◽  
Author(s):  
Pierre Martel ◽  
Tibor Kovacs ◽  
Virginie Bérubé
Keyword(s):  
Laboratory Tests ◽  
Egg Production ◽  
Pimephales Promelas ◽  
Paper Mill ◽  
Pulp And Paper ◽  
Reproductive Capacity ◽  
Fish Reproduction ◽  
Pulp And Paper Mill ◽  
Paper Mill Effluents ◽  
Gonad Size

Abstract Pulp and paper mill effluents have been reported to cause changes in reproductive indicators of fish in laboratory and field studies. These changes include reduced egg production and gonad size, and altered hormone levels and expression of secondary sex characteristics. We examined the performance of biotreatment plants for their potential in abating effects of pulp and paper mill effluents on fish reproduction under laboratory conditions. A bleached kraft mill effluent (BKME) treated in an aerated lagoon and a thermomechanical pulp mill effluent (TMPE) treated by aerobic sludge in a sequential batch reactor were selected for study. Mature fathead minnows (Pimephales promelas) were exposed to effluents before and after biotreatment under continuous renewal conditions for 21 days. Egg production was monitored daily, while morphometric parameters (length, weight, gonad size), secondary sexual characteristics, and steroid hormone and vitellogenin levels were measured at the end of the effluent exposure. The effluent from both mills before biotreatment impaired the reproductive capacity of minnows (egg production) at concentrations of 10 and 20% vol/vol, but not at 2% vol/vol. Exposure to biotreated effluents from both mills at concentrations of 2, 10, 20, and 40% vol/vol caused no significant differences in overall reproductive capacity of minnows as compared with controls. These results indicate that biotreatment can significantly improve the quality of a BKME and an effluent from a TMP mill with respect to the reproductive capacity of fish as determined in laboratory tests.

Mutagenicity in Pulp and Paper Mill Effluents and in Recipient

1988 ◽  
Vol 20 (2) ◽  
pp. 143-152 ◽  
Author(s):  
A. Langi ◽  
M. Priha
Keyword(s):  
Activated Sludge ◽  
Mutagenic Activity ◽  
Chinese Hamster Ovary Cells ◽  
Chinese Hamster ◽  
Paper Mill ◽  
Pulp And Paper ◽  
Pulp And Paper Mill ◽  
Sludge Treatment ◽  
Paper Mill Effluents ◽  
Kraft Mill

The mutagenic properties of pulp and paper mill effluents were studied in three mills: bleached kraft mill with aerated lagoon treatment (Mill 1), bleached kraft mill with activated sludge treatment (Mill 2) and mechanical pulp/paper mill (Mill 3). Both treated and untreated effluents, process streams and molecular fractions were tested for mutagenicity (Ames test. Salmonella typhimurium TA100 and SCE sister chromatid exchange test, Chinese hamster ovary cells). To verify the potential environmental effects the mutagenic activity of concentrated recipient lake water (Mill 2) was also studied. The Ames mutagenicity of the bleached kraft mill effluent (BKME) originated from the first chlorination filtrate, SCE mutagenicity also occurred in the alkali extraction stage filtrate (Mill 1). No Ames mutagenicity was detected in the paper mill effluent, but it was SCE mutagenic. Activated sludge treatment of BKME removed both Ames and SCE mutagenicity, but the aerated lagoon treated BKME was still SCE mutagenic. No mutagenic activity was detected in the recipient water concentrates.

Effects of Pulp and Paper Mill Effluents on Reproduction, Bile Conjugates and Liver MFO (Mixed Function Oxygenase) Activity in Fish at Southern Lake Saimaa, Finland

1999 ◽  
Vol 40 (11-12) ◽  
pp. 109-114 ◽  
Author(s):  
Aarno Karels ◽  
Markus Soimasuo ◽  
Aimo Oikari
Keyword(s):  
Endocrine Disrupting Compounds ◽  
Paper Mill ◽  
Erod Activity ◽  
Pulp And Paper ◽  
Coregonus Lavaretus ◽  
Pulp And Paper Mill ◽  
Paper Mill Effluents ◽  
Mixed Function Oxygenase ◽  
Estradiol 17Β ◽  
Lake Saimaa

Reproductive indices like gonad size, fecundity, egg size and sex steroid levels of estradiol-17β and testosterone, vitellogenin in the blood as well as bile conjugates and liver 7-ethoxyresorufin O-deethylase (EROD) activity were studied in populations of perch (Perca fluviatilis L.) and roach (Rutilus rutilus L.) and experimentally exposed juvenile whitefish (Coregonus lavaretus L. s.l.) at the Southern Lake Saimaa (S.E. Finland). Our studies showed that the introduction of elemental chlorine free (ECF) bleaching and secondary treatment of effluents in a modern activated sludge plant at the mill in 1992 have substantially reduced the exposure of feral and caged fish to organochlorines. The liver EROD activity was noticeably lower in feral and caged fish near the mill indicating lesser impacts on the liver mixed function oxygenase (MFO) system. However, at the mill site, liver EROD activies in feral and caged fish still tend to be one to four times higher than at the reference sites. Significantly decreased plasma estradiol-17β and testosterone concentrations in perch and roach in the period of development of the gonads (autumn and winter) indicate that there were endocrine disrupting compounds present in the lake receiving ECF pulp and paper mill effluents. Cause-effect relationships, however, are difficult to establish.

Sign in / Sign up

Export Citation Format

Share Document