scholarly journals Effect of microbial phytase and diet fermentation on ileal and total tract digestibility of nutrients and energy in growing pigs

2009 ◽  
Vol 54 (No. 4) ◽  
pp. 163-174 ◽  
Author(s):  
S. Nitrayová ◽  
P. Patráš ◽  
M. Brestenský ◽  
J. Zelenka ◽  
J. Brož ◽  
...  
Keyword(s):  
Amino Acids ◽  
Dry Matter ◽  
Latin Square ◽  
Growing Pigs ◽  
Deficient Diet ◽  
Ileal Digestibility ◽  
Laboratory Setup ◽  
Microbial Phytase ◽  
Four Levels ◽  
Dry Diet

A digestibility experiment using six ileally cannulated growing gilts (initial BW 31.6 kg) was carried out to study the effect of microbial phytase and diet form on apparent ileal and total tract digestibilities of dry matter (DM), nitrogen (N), phosphorus (P), calcium (Ca) and energy and on apparent ileal digestibility of amino acids. The basal P-deficient diet was fed either dry or mixed with water (feed:water ratio 1:2.5) and fermented in a laboratory setup. The enzyme was added to the dry diet at four levels (0, 1 000, 1 500 and 3 000 U/kg) and to the liquid fermented diet at two levels (0 and 1 000 U/kg) using a 6 × 6 Latin square design. The supplementation of microbial phytase to the basal diets significantly (<I>P</I> < 0.05) improved ileal and total tract digestibility of P and tended to improve the digestibility of Ca. Phytase supplementation at 3 000 U/kg to the dry diet improved ileal and total tract P digestibility by approximately 30 and 60%, respectively. A similar effect was found in the liquid fermented diet supplemented with phytase at 1 000 U/kg. As a result of improved P digestibility, faecal P excretion was reduced by 20–40%. There was no significant effect of phytase addition or diet fermentation on the digestibility of DM, N, energy or amino acids. The response in amino acid digestibility to phytase calculated with acid insoluble ash as a marker was slightly higher than that calculated with Cr<sub>2</sub>O<sub>3</sub>.

scholarly journals A new source of high-protein distillers dried grains with solubles (DDGS) has greater digestibility of amino acids and energy, but less digestibility of phosphorus, than de-oiled DDGS when fed to growing pigs

2020 ◽  
Vol 98 (7) ◽  
Author(s):  
Minoy Cristobal ◽  
Jessica P Acosta ◽  
Su A Lee ◽  
Hans H Stein
Keyword(s):  
Amino Acids ◽  
Crude Protein ◽  
Block Design ◽  
Latin Square ◽  
Sole Source ◽  
Growing Pigs ◽  
Ileal Digestibility ◽  
Distillers Dried Grains ◽  
Randomized Complete Block Design ◽  
Microbial Phytase

Abstract AbstractThree experiments were conducted to test the hypothesis that standardized ileal digestibility (SID) of amino acids (AA), concentration of metabolizable (ME), and standardized total tract digestibility (STTD) of P in a new source of distillers dried grains with solubles (DDGS; ProCap DDGS) are greater than in conventional de-oiled DDGS. In experiment 1, nine barrows (initial BW: 67.2 ± 6.4 kg) with a T-cannula in the distal ileum were allotted to a triplicated 3 × 3 Latin square design with three diets and three periods for a total of nine replicate pigs per diet. Two diets included ProCap DDGS or de-oiled DDGS as the sole source of crude protein (CP) and AA. An N-free diet was used to determine the basal endogenous losses of CP and AA. Ileal digesta were collected on days 5 and 6 of each period after 4 d of adaptation to diets. Results from experiment 1 indicated that ProCap DDGS contained more CP and AA compared with de-oiled DDGS. The SID of all AA in ProCap DDGS was greater (P &lt; 0.001) compared with de-oiled DDGS with the exception that the SID of Pro was not different between the two sources of DDGS. In experiment 2, 24 growing barrows (initial BW: 32.7 ± 3.1 kg) were housed individually in metabolism crates and used in a randomized complete block design and fed a corn-based diet or two diets containing corn and each source of DDGS with eight replicate pigs per diet. Fecal and urine samples were collected for 4 d after 7 d of adaptation. Results from experiment 2 indicated that concentration of ME in ProCap DDGS was greater (P &lt; 0.05) compared with corn or de-oiled DDGS. In experiment 3, 32 growing barrows (initial BW: 20.2 ± 0.9 kg) were placed in metabolism crates and allotted to four diets with eight pigs per diet using a 2 × 2 factorial treatment arrangement. The de-oiled DDGS and ProCap DDGS were both included in a diet without microbial phytase and a diet with microbial phytase (500 units/kg diet). Pigs were adapted to the diets for 5 d and fecal samples were collected for 4 d. Results from experiment 3 indicated that inclusion of phytase in the diet containing ProCap DDGS increased (P &lt; 0.05) the STTD of P, but addition of phytase to the de-oiled DDGS diet did not increase STTD of P (interaction, P &lt; 0.001), but the STTD of P was greater (P &lt; 0.05) in de-oiled DDGS compared with ProCap DDGS. In conclusion, ProCap DDGS has greater SID of AA and contains more ME, but has reduced STTD of P compared with conventional de-oiled DDGS.

Effect of fermentation of soybean meal with varying protein solubility on ileal digestibility of nutrients in growing pigs

2016 ◽  
Vol 56 (12) ◽  
pp. 2023
Author(s):  
Santi D. Upadhaya ◽  
Je-hoon Ryu ◽  
Kyung-il Kang ◽  
Seong-Jun Cho ◽  
In Ho Kim
Keyword(s):  
Amino Acids ◽  
Soybean Meal ◽  
Crude Protein ◽  
Dry Matter ◽  
Protein Solubility ◽  
Latin Square ◽  
Growing Pigs ◽  
Ileal Digestibility ◽  
Fermented Soybean Meal ◽  
Fermented Soybean

Apparent ileal digestibility and standardised ileal digestibility of energy, dry matter, nitrogen and amino acids were evaluated in five cannulated [(Landrace × Yorkshire) × Duroc)] barrows with an initial bodyweight of 27.1 ± 0.58 kg in a 5 × 5 Latin square design. Pigs were fed unfermented soybean meal (USM) as control and fermented soybean meal A, B and C (FSMA, FSMB and FSMC, respectively), with 52.4%, 62.0% and 71.8% protein solubility, respectively, and a nitrogen-free diet. The nitrogen-free diet was used to determine basal endogenous losses of crude protein and amino acids. The apparent ileal digestibility of dry matter and nitrogen was greater (P < 0.05) in FMSC and tended to improve in FSMA and FSMB compared with the control. The apparent ileal digestibility of isoleucine, phenylalanine and valine was greater in all fermented soybean meal whereas that of lysine was greater (P < 0.05) in FSMC compared with USM. Likewise, the apparent ileal digestibility of aspartic acid and proline was greater (P < 0.05) in FSMA and FSMC. The standardised ileal digestibility of crude protein and lysine was higher (P < 0.05) in FSMC and tended to improve in FSMA and FSMB whereas the standardised ileal digestibility of isoleucine was higher (P < 0.05) in FSMA, FSMB and FSMC compared with USM. In conclusion, fermentation of soybean meal showed better digestibility compared with USM regardless of its protein solubility values.

The effect of microbial phytase in diets for pigs on apparent ileal and faecal digestibility, pH and flow of digesta measurements in growing pigs fed a high-fibre diet

1995 ◽  
Vol 75 (1) ◽  
pp. 121-127 ◽  
Author(s):  
J. A. M. Bruce ◽  
F. Sundstøl
Keyword(s):  
Crude Protein ◽  
Dry Matter ◽  
Latin Square ◽  
Growing Pigs ◽  
Crude Fibre ◽  
Ph Measurements ◽  
Ileal Digestibility ◽  
Fibre Diet ◽  
High Fibre ◽  
Microbial Phytase

The effect of Aspergillus niger phytase on digestibility of some nutrients, pH and flow of digesta in post valvular T-caecum (PVTC) cannulated growing pigs fed an oat (80.6%) diet was studied. Four barrows weighing on average 40 kg were assigned to four diets in a 4 × 4 Latin square design. Diet 1 contained 1.11% monocalcium phosphate (MCP); diet 2 had neither MCP nor phytase; diet 3 included phytase at a concentration of 487 phytase units kg−1 feed; and diet 4 had 0.55% MCP and 320 phytase units kg−1 feed. Ileal digestibility of phosphorus (P) increased by 19.4 and 26.8% in diets containing microbial phytase compared with the control diets 1 and 2, respectively. Corresponding increases in faecal digestibility values were 18.3 and 23.6%. Ileal digestibility of calcium (Ca) was significantly higher in diet 3 but there was no effect of diet on the faecal digestibility of Ca. There was no effect of microbial phytase on the digestibility of magnesium (Mg), dry matter (DM) or crude protein (CP). Ileal digestibility of crude fibre (CF) was not affected by diet, but faecal CF digestibility was lower (P < 0.05) in diets containing microbial phytase. There was no effect of phytase on excretion of Ca, Mg and N and Mg and N retention. There was a time-related response of pH of ileal digesta, with hourly pH measurements ranging between 7.1 and 5.9, irrespective of diet. Flow of digesta peaked 3–6 h after the morning feed and 1–2 hours after the evening feed. Key words: Pigs, cannulation, phytase, digestibility, pH

scholarly journals PSIV-21 Pellet processing reduces variability of corn soybean meal-based diet digestibility in growing pigs

2020 ◽  
Vol 98 (Supplement_3) ◽  
pp. 175-175
Author(s):  
Élisabeth Chassé ◽  
Frédéric Guay ◽  
Marie-Pierre Létourneau-Montminy
Keyword(s):  
Amino Acids ◽  
Soybean Meal ◽  
Crude Protein ◽  
Dry Matter ◽  
Crossover Design ◽  
Growing Pigs ◽  
Distal Ileum ◽  
Ileal Digestibility ◽  
Pelleted Diet ◽  
The One

Abstract This study was conducted to determine the effect of pelleting on the digestibility of corn-soybean meal-based diet in growing pigs. Two trials with 6 pigs cannulated at the distal ileum were conducted. In each trial, pigs were assigned to each treatment following a crossover design. In each experiment, the same diet, composed of corn and soybean meal with 10% wheat from two different feed mills, was served in pellet or mash form. Pelleting allowed an increase in digestibility in one of the trials. Apparent ileal digestibility (AID) of dry matter (DM), crude protein (CP) and digestible energy (DE) were improved with pelleting by 8, 12 and 9% (P&lt; 0.01). The AID of amino acids (AA) was also improved (P&lt; 0.05). Apparent total tract digestibility (ATTD) was increased by pelleting in DM, CP and DE by 5, 7 and 6% respectively (P&lt; 0.01). The digestibility of the mash diet in experiment 1 was lower than in the pelleted diet in the experiment 1 and both diets in experiment 2 as shown by the interaction Pelleting X Trial which was significant for the AID and ATTD of DM, CP and DE (P&lt; 0.01). Therefore, in experiment 1, pelleting allows to improve the digestibility of diet to the same level as in experiment 2. The AID of CP was higher by 37% in the mash diet from the second experiment compared to the one in the first experiment. Even though the same ingredients were chosen in the two experiments, this shows the variability in digestibility existing between different feed mills and ingredient sources. This difference was not observed in pelleted diets. The results obtained in these two trials show that pelleting can reduce the variability of digestibility and then give a good digestibility of diets even if the ingredients are of different quality or sources.

Effects of xylanase and antibiotic addition on ileal and faecal apparent digestibilities of dietary nutrients and evaluating HCl-insoluble ash as a dietary marker in growing pigs

2001 ◽  
Vol 72 (1) ◽  
pp. 95-103 ◽  
Author(s):  
Y.-L. Yin ◽  
J.D. McEvoy ◽  
H. Schulze ◽  
K.J. McCracken
Keyword(s):  
Amino Acids ◽  
Crude Protein ◽  
Dry Matter ◽  
Growing Pigs ◽  
Ileal Digestibility ◽  
Neutral Detergent Fibre ◽  
Protein Energy ◽  
Dietary Nutrients

AbstractThe effects of xylanase and antibiotic addition to the diet, and the use of HCl-insoluble ash as a marker, on ileal and faecal apparent digestibilities of nutrients were studied with 12 growing pigs fitted with post-valvular T-caecum cannulae (PVTC). The results showed that the apparent ileal digestibility of non-starch polysaccharide (NSP) was high, (over 0·30). Xylanase, or antibiotics (Avoparcin) or xylanase plus antibiotics supplementation of the wheat middling-based diets did not significantly (P > 0·05) increase the ileal and faecal apparent digestibilities of NSP, neutral-detergent fibre (NDF), dry matter, crude protein, energy or amino acids. There were no significant (P > 0·05) differences between the HCl-insoluble ash and Cr2O3 recoveries at the ileal or at the faecal levels: proportionately, 0·864 and 0·911 for the ileal and faecal recoveries of HCl-insoluble ash, and 0·857 and 0. 915 for the ileal and faecal recoveries of Cr2O3, respectively.

Sunflower expellers have greater ileal digestibility of amino acids than sunflower meal, but there are only minor variations among different sources of sunflower meal when fed to growing pigs

2021 ◽  
Author(s):  
Jimena A Ibagon ◽  
Su A Lee ◽  
Hans H Stein
Keyword(s):  
Amino Acids ◽  
Crude Protein ◽  
Nutritional Value ◽  
Latin Square ◽  
Growing Pigs ◽  
The Other ◽  
Sunflower Meal ◽  
Ileal Digestibility ◽  
Different Sources ◽  
The U.S

Abstract The objective was to test the hypothesis that there is no effect of origin or processing procedure on the standardized ileal digestibility (SID) of amino acids (AA) and crude protein (CP) in sunflower co-products. Six sources of sunflower meal (SFM) and 1 source of sunflower expellers (SFE) were obtained from Ukraine, Italy, Hungary, and the U.S. Each source of SFM or SFE was the only source of CP and AA in 1 diet and an N-free diet was also used for a total of 8 diets. Eight barrows (body weight: 28.5 ± 2.4 kg) had a T-cannula installed in the distal ileum and were allotted to 1 of the 8 diets using an 8 × 8 Latin square design with 8 periods. The Lys:CP ratio in the 6 sources of SFM ranged from 3.10 to 3.96% with CP concentrations ranging from 27.34 to 36.75%. Crude protein in SFE was 26.87% and the Lys:CP ratio was 3.51%. Concentrations of acid hydrolyzed ether extract in the 6 sources of SFM ranged from 0.60 to 3.11%, but SFE contained 8.77%. Results indicated that the SID of CP was lower (P &lt; 0.05) in SFM from Hungary compared with all other sources of SFM except for 1 of the sources from Ukraine. There were no differences in the SID of Lys, Met, and Trp among sources of SFM, but for most of the remaining indispensable AA, the SFM from Hungary had less (P &lt; 0.05) SID than the other sources. However, only few differences in SID of indispensable AA were observed among the other sources of SFM, but the SID of CP and all AA except Trp was greater (P &lt; 0.05) in SFE compared with SFM. In conclusion, there were only few differences in the SID of the first limiting AA among SFM obtained from Ukraine, Hungary, Italy, and the U.S., but the SID of CP and AA was greater in SFE than in SFM indicating that processing of sunflower seeds influence the nutritional value.

scholarly journals Nutritive value of enzyme-supplemented carinata meal for growing pigs1

2019 ◽  
Vol 3 (4) ◽  
pp. 1359-1368
Author(s):  
Jinsu Hong ◽  
Jung Wook Lee ◽  
Dan Pettersson ◽  
Tofuko A Woyengo
Keyword(s):  
Dry Matter ◽  
Nutritive Value ◽  
Latin Square ◽  
Basal Diet ◽  
Growing Pigs ◽  
Net Energy ◽  
Ileal Digestibility ◽  
Degrading Enzymes ◽  
Livestock Feeding ◽  
The Difference

Abstract Carinata meal is increasingly available for livestock feeding. However, the effects of supplemental phytase and fiber degrading enzymes on nutritive value of carinata meal for pigs have not been reported. Objective of the study was to evaluate the standardized ileal digestibility (SID) of amino acid (AA), and digestible energy (DE) and net energy (NE) values of phytase- and fiber-degrading enzymes-supplemented carinata meal for growing pigs. Ten ileal-cannulated pigs (initial body weight = 53.9 ± 4.76 kg) were fed 4 diets in a replicated 4 × 4 Latin square design with two additional columns to give 10 replicates per diet. Diets included a corn-soybean meal (SBM)-based basal diet, basal diet with 25% carinata meal, basal diet with 25% carinata meal plus phytase at 2,000 FTU/kg and multi-carbohydrase at 0.2 g/kg, and in addition a nitrogen-free diet. The multicarbohydrase supplied 4 units of xylanase, 10 units of β-glucanase, and 1,000 units of pectinase per kilogram of diet. The ratio of corn to SBM and soybean oil in carinata meal-containing diets was identical to that in the corn-SBM-based basal diet to allow calculation of AA and energy digestibility of carinata meal by the difference method. On a dry matter basis, carinata meal contained 50.2% crude protein, 0.88% ether extract, 15.37% acid detergent fiber, 1.82% Lys, 0.96% Met, 1.89% Thr, and 0.64% Trp, respectively. The SID of Lys, Met, Thr, and Trp for carinata meal were 51.4%, 82.2%, 65.9%, and 85.9%, respectively. The DE and NE values for carinata meal were 3,427 and 1,828 kcal/kg of dry matter, respectively. Supplementation of a combination of phytase and multicarbohydrase did not affect the apparent ileal digestibility of AA and SID of AA for the corn-SBM-carinata meal-based diet, and for the carinata meal. However, the combination of phytase and multicarbohydrase did improve (P &lt; 0.05) apparent total tract digestibility, and DE and NE values for carinata meal by 9.4%, 9.5%, and 12.4%, respectively. In conclusion, the enzymes used in the current study could be added in carinata meal-based diets for growing pigs to improve the energy value.

scholarly journals Effect of microbial phytase on apparent digestibility and retention of phosphorus and nitrogen in growing pigs

2011 ◽  
Vol 51 (No. 10) ◽  
pp. 437-443 ◽  
Author(s):  
P. Patráš ◽  
S. Nitrayová ◽  
A. Sommer ◽  
J. Heger
Keyword(s):  
Latin Square ◽  
Growing Pigs ◽  
Apparent Digestibility ◽  
Ileal Digestibility ◽  
Protein Deposition ◽  
P Concentration ◽  
Microbial Phytase ◽  
Lower Protein ◽  
Net Flux ◽  
Total P

Six female pigs of approximately 50 kg BW, fitted with simple T-cannula in the terminal ileum, were used to study the effect of microbial phytase on apparent total tract digestibility and retention of P and N. Three P-adequate diets (digestible P concentration 2.3 g/kg) containing barley (B), soybean meal (S) or their mixture (BS) with or without phytase supplement (1 000 FTU/kg) were fed to pigs using a 6 &times; 6 Latin square design. The addition of phytase increased (P &lt; 0.05) apparent total P digestibility of diets S and BS from 56.5 and 57.2% to 69.0 and 65.2%, respectively, and apparent plant P digestibility of the same diets from 41.3 and 50.0% to 60.5 and 60.0%, respectively. An insignificant improvement in total and plant P digestibilities was found in diet B. Phytase supplementation reduced (P &lt; 0.05) P excretion in pigs fed diets S and BS by 25 and 14%, respectively. As compared with diets S and BS, urinary P excretion in pigs fed diet B was much higher, which suggests a lower requirement for available P due to the lower protein deposition and growth rate. Phytase supplementation had no effect on digestibility or retention of N. In all three diets, total tract P digestibility was lower (P &lt; 0.05) than ileal digestibility thus indicating a net flux of P into the large intestine. &nbsp;

scholarly journals 154 Digestibility of amino acids, fiber, and energy, and concentrations of digestible and metabolizable energy in conventional and extruded yellow dent corn, wheat, and sorghum fed to growing pigs

2019 ◽  
Vol 97 (Supplement_2) ◽  
pp. 85-86
Author(s):  
Diego A Rodriguez ◽  
Su A Lee ◽  
Mary B Muckey ◽  
Cassandra K Jones ◽  
Hans H Stein
Keyword(s):  
Amino Acids ◽  
Latin Square ◽  
Nutrient Digestibility ◽  
Growing Pigs ◽  
Metabolizable Energy ◽  
Distal Ileum ◽  
Ileal Digestibility ◽  
Dent Corn

Abstract Two experiments were conducted to determine the effects of extrusion on energy and nutrient digestibility in corn, wheat, and sorghum fed to growing pigs. In Exp. 1, 6 diets based on raw or extruded sources of each grain and an N-free diet were formulated. Seven barrows (14.2 ± 0.9 kg) had a T-cannula installed in the distal ileum and were allotted to a 7 × 7 Latin square. Ileal digesta were collected for 2 d after 5 d of adaptation. Results indicated that extruded grains had greater (P < 0.001) apparent ileal digestibility (AID) of starch than non-extruded grains. Extrusion increased standardized ileal digestibility (SID) of all AA except Pro in corn, but SID of AA in wheat and sorghum was not affected by extrusion (Table 1). In Exp. 2, 48 barrows (15.1 ± 3.7 kg) were allotted to 6 diets based on each of the 6 grains. Pigs were housed individually in metabolism crates and feces and urine were collected quantitatively for 5 d after 5 d of adaptation. The apparent total tract digestibility (ATTD) of GE increased by extrusion of corn or sorghum, but that was not the case for wheat (interaction, P < 0.001). The ATTD of NDF was reduced by extrusion of wheat, but not of corn or sorghum (interaction, P < 0.001). Extrusion reduced (P < 0.05) the ATTD of ADF in all grains. Values for ME were greater in extruded corn and sorghum compared with non-extruded grains, but ME in wheat was not affected by extrusion (interaction, P < 0.001). In conclusion, extrusion of corn, wheat, and sorghum increased AID of starch and SID of all indispensable AA. The ME in corn and sorghum was also increased.

scholarly journals 199 Effect of the Pelleting Process on Diet Formulations with Varying Levels of Crystalline Amino Acids and Reducing Sugars on Digestibility in Growing Pigs

2021 ◽  
Vol 99 (Supplement_1) ◽  
pp. 66-67
Author(s):  
Kara M Dunmire ◽  
Diego A Lopez ◽  
Chance J Fiehler ◽  
Yiqin Zhang ◽  
Cassandra K Jones ◽  
...  
Keyword(s):  
Amino Acids ◽  
Reducing Sugars ◽  
Latin Square ◽  
Growing Pigs ◽  
Ileal Digestibility ◽  
Distillers Grains With Solubles ◽  
Feed Form ◽  
Low Crystalline ◽  
Crystalline Amino Acids ◽  
Main Effects

Abstract The objective of this study was to determine effects of pelleting on the standardized ileal digestibility (SID) of amino acids (AA) in diets with or without increased concentrations of free AA and reducing sugars (RS). Eight individually housed, ileal cannulated barrows (initially 69.2 kg) were allotted to a replicated 8×8 Latin square with 8 diets and eight 7-d periods with ileal digesta collected on d 6 and 7. Treatments were arranged in a 2×2×2 factorial with main effects of diet form (mash vs. pellet), crystalline AA (low vs. high), or reducing sugars (low vs. high) provided by dried distillers grains with solubles and bakery meal. Diets were pelleted to achieve a hot pellet temperature of 85 to 88°C. Data were analyzed as a completely randomized Latin square using the GLIMMIX procedure of SAS. A feed form×RS interaction (P &lt; 0.026) for SID of tryptophan was observed. Feeding pelleted low RS diets improved SID of tryptophan compared with mash high and low RS diets, and pelleted high RS diets. For main effects of feed form, the SID of total AA, CP, and indispensable AA increased (P &lt; 0.042) in pigs fed pelleted diets compared with mash diets. For main effects of crystalline AA, pigs fed high crystalline AA had increased (P = 0.007) SID of tryptophan and decreased (P = 0.050) SID of histidine compared with those fed low crystalline AA diets. For main effects of RS diets, pigs fed high RS diets had decreased (P &lt; 0.05) SID of total AA, CP and indispensable AA. In conclusion, pelleting diets with increased crystalline AA or RS did not affect the improvement in AA digestibility from pelleting. Pelleting diets improved AA digestibility. Diets formulated with high crystalline AA had increased SID of tryptophan. Formulating diets with high RS resulted in decreased AA digestibility compared with corn-soybean meal-based diets.

Sign in / Sign up

Export Citation Format

Share Document