An experimental study of alkali soil improvement with coal ash and coal shale

2011 ◽  
Author(s):  
Qiguo Zeng ◽  
Miao Yang ◽  
Jingji Li ◽  
Peihao Peng ◽  
Fan Luo ◽  
...  
Keyword(s):  
Experimental Study ◽  
Coal Ash ◽  
Soil Improvement ◽  
Alkali Soil

Pengaruh Penggunaan Batu Basalt Lampung dan Batubara dalam Bahan Baku terhadap Karakteristik Klinker

2020 ◽  
Vol 10 (1) ◽  
pp. 49
Author(s):  
Suharto Suharto ◽  
Muhammad Amin ◽  
Muhammad Al Muttaqii ◽  
Syafriadi Syafriadi ◽  
Kiki Nurwanti
Keyword(s):  
Experimental Study ◽  
Raw Materials ◽  
Coal Ash ◽  
Heating Time ◽  
Raw Material ◽  
Silica Sand ◽  
Cement Clinker ◽  
Duration Of Heating

Experimental study on the use of basalt stone originated from Lampung has been conducted to evaluate its potential for a partial substitute of raw material in production of cement clinker. The basalt stone contains minerals of anorthite, augite, and albite phases that are required for clinker formation. In this study, the main raw materials were 80% limestone, 10% silica sand, 9% clay and 1% iron sand. The raw material in these experiments were mixtures 90% or 80% of the main raw material and 10% or 20% of basalt stone. The effect of adding coal to raw materials was also studied to see the possibility of an increase in clinkerization temperature inside the raw material mixture, and at the same time to see the effect of coal ash on clinker composition. Clinker obtained from heating of raw materials at a temperature of 1100oC had LSF of 94.1% and 95.1% (heating time of 1 and 3 hours). If heating is carried out at 1200oC, the clinker had LSF of 97.7% and 98.0% (heating time of 2 and 3 hours, respectively). Depending on the temperature and duration of heating, the clinker mostly had SM in the range of 2.18-2.40% , and AM in the range of 0,78-1.80%. Characterization using XRD showed that the clinker consisted of larnite and gehlenite phases, and dominated by CaO.Batu basalt Lampung telah diuji potensinya sebagai pengganti sebagian bahan baku utama pembuatan klinker semen. Batu basalt tersebut memiliki mineral-mineral dalam fase anorthite, augite, dan albite yang diperlukan pada pembentukan klinker. Pada penelitian ini, bahan baku utama adalah batu kapur 80%, pasir silika 10%, tanah liat 9% dan pasir besi 1%. Campuran bahan baku klinker adalah 90% atau 80% bahan baku utama dan 10% atau 20% batu basalt. Efek penambahan batubara ke dalam bahan baku klinker juga dipelajari untuk melihat kemungkinan kenaikan temperatur klinkerisasi di dalam campuran bahan baku, dan sekaligus untuk melihat efek abu batubara terhadap komposisi klinker. Klinker hasil pemanasan bahan baku pada temperatur 1100oC memiliki LSF 94,1% dan 95,1% (lama pemanasan 1 dan 3 jam). Jika pemanasan dilakukan pada 1200oC, klinker memilik LSF 97,7% dan 98,00% (lama pemanasan 2 dan 3 jam). Tergantung pada temperatur dan lama pemanasan, klinker hasil percobaan ini umumnya memiliki SM 2,18-2,40%, dan AM antara 0,78-1,80%. Karakterisasi dengan XRD menunjukkan bahwa klinker terdiri dari fase larnite dan gehlenite, dan didominasi CaO.

Microstructure and Mechanical Properties of Ambiently-Cured Blended Coal Ash-Based Geopolymer Concrete

2016 ◽  
Vol 857 ◽  
pp. 400-404
Author(s):  
Tian Yu Xie ◽  
Togay Ozbakkaloglu
Keyword(s):  
Mechanical Properties ◽  
Experimental Study ◽  
Compressive Strength ◽  
Fly Ash ◽  
Bottom Ash ◽  
Coal Ash ◽  
Geopolymer Concrete ◽  
Mass Ratio ◽  
Blended Coal ◽  
Microstructure And Mechanical Properties

This paper presents the results of an experimental study on the behavior of fly ash-, bottom ash-, and blended fly and bottom ash-based geopolymer concrete (GPC) cured at ambient temperature. Four bathes of GPC were manufactured to investigate the influence of the fly ash-to-bottom ash mass ratio on the microstructure, compressive strength and elastic modulus of GPC. All the results indicate that the mass ratio of fly ash-to-bottom ash significantly affects the microstructure and mechanical properties of GPCs

Experimental Study of Bottom Coal Ash-Geogrid Interaction

2014 ◽  
Author(s):  
Miguel A. Pando ◽  
Robert H. Swan, Jr. ◽  
Youngjin Park ◽  
Scott Sheridan
Keyword(s):  
Experimental Study ◽  
Coal Ash

Experimental study on flow properties of coal ash slag based on the image measurement method

2021 ◽  
Author(s):  
Jiawei Luo ◽  
Hao Zhou ◽  
Zhaowen Wang ◽  
Mengting Ji ◽  
Hanxiao Meng ◽  
...  
Keyword(s):  
Experimental Study ◽  
Measurement Method ◽  
Coal Ash ◽  
Flow Properties ◽  
Image Measurement

Experimental study of the high-temperature slagging characteristics of coal ash-biomass ash blends under different atmospheres

2019 ◽  
Vol 92 (6) ◽  
pp. 1914-1925 ◽  
Author(s):  
Yongfeng Qi ◽  
Shun Ji ◽  
Meiting Wang ◽  
Panle Ge ◽  
Ru Ma ◽  
...  
Keyword(s):  
Experimental Study ◽  
High Temperature ◽  
Coal Ash ◽  
Biomass Ash
Sign in / Sign up

Export Citation Format

Share Document