The Oxidation of Vulcanized Rubber

1929 ◽  
Vol 2 (3) ◽  
pp. 341-355
Author(s):  
A. Van Rossem ◽  
P. Dekker

Abstract SINCE Kirchhof in June, 1927, gave to the first general meeting of the German Rubber Society in Essen a detailed review of work concerned with the oxidation of rubber, it seems superfluous to publish any extensive bibliography thereon. We prefer to limit ourselves, for the present, almost exclusively to a few experiments in this field. However, we may refer in a general way to the work of others. It is a notable fact that all investigations of the oxidation of vulcanized rubber have been always based on the kinetics of the oxygen combination, and, as far as isolation of the oxidation products is concerned, on a late stage of oxidation, the isolation of oxidation products during the early stages of oxidation being left out of consideration. Thus, for example, Kirchhof in his work published in 1913 studied the behavior of ground vulcanized rubber which had been heated for 100 hours in a current of air at 100° C. and thereby strongly oxidized, as indicated by the increase in weight (11–13%). Eaton and Day later in 1919 made experiments of a similar nature. Here, too, the kinetics principally were studied, and the samples were examined only after oxidation was far advanced. Again in Kirchhof's recent work already mentioned, the oxidation products were studied only after prolonged oxidation.

1951 ◽  
Vol 24 (4) ◽  
pp. 853-856
Author(s):  
A. S. Kuzminskii˘ ◽  
T. G. Degteva ◽  
K. A. Lapteva ◽  
N. N. Lezhnev

Abstract In the vulcanization of rubber and in the service performance of vulcanized rubber products, oxygen and free sulfur are always present. Consequently it is important to know the effect of sulfur on the oxidation of rubber. The present work is devoted to an investigation of the oxidation of a sodium-butadiene polymer in the presence of sulfur. Dogadkin and his associates established the fact that oxygen has an influence on the nature of the structural changes of rubber during vulcanization. The present authors have shown that any sulfur which is chemically combined with rubber does not appreciably affect the kinetics of its oxidation, and that free sulfur, in solution in rubber, interferes with autocatalytic oxidation. The higher the concentration of sulfur, the greater is this interference (see Figure 1). Introduction of sulfur into rubber during autocatalysis does not prevent the autocatalytic process, but hinders it noticeably (see Figure 2). The introduction of a secondary aromatic amine has been observed to arrest the process altogether. This behavior of sulfur can be explained by its ability to react with intermediate oxidation products, since the rate of combination of sulfur is practically constant (see Figure 3).


2018 ◽  
Vol 19 (10) ◽  
pp. 2868 ◽  
Author(s):  
Luiza Bertozo ◽  
Ernesto Tavares Neto ◽  
Leandro Oliveira ◽  
Valdecir Ximenes

Human serum albumin (HSA) is a target for reactive oxygen species (ROS), and alterations of its physiological functions caused by oxidation is a current issue. In this work, the amino-acid residues Trp-214 and Lys-199, which are located at site I of HSA, were experimentally and computationally oxidized, and the effect on the binding constant with phenylbutazone was measured. HSA was submitted to two mild oxidizing reagents, taurine monochloramine (Tau-NHCl) and taurine dibromamine (Tau-NBr2). The oxidation of Trp-214 provoked spectroscopic alterations in the protein which were consistent with the formation of N′-formylkynurenine. It was found that the oxidation of HSA by Tau-NBr2, but not by Tau-NHCl, provoked a significant increase in the association constant with phenylbutazone. The alterations of Trp-214 and Lys-199 were modeled and simulated by changing these residues using the putative oxidation products. Based on the Amber score function, the interaction energy was measured, and it showed that, while native HSA presented an interaction energy of −21.3 kJ/mol, HSA with Trp-214 altered to N′-formylkynurenine resulted in an energy of −28.4 kJ/mol, and HSA with Lys-199 altered to its carbonylated form resulted in an energy of −33.9 kJ/mol. In summary, these experimental and theoretical findings show that oxidative alterations of amino-acid residues at site I of HSA affect its binding efficacy.


1932 ◽  
Vol 7 (2) ◽  
pp. 149-161 ◽  
Author(s):  
W. H. Hatcher ◽  
E. W. R. Steacie ◽  
Frances Howland

The kinetics of the oxidation of gaseous acetaldehyde have been investigated from 60° to 120 °C. by observing the rate of pressure decrease in a system at constant volume. A considerable induction period exists, during which the main products of the reaction are carbon dioxide, water, and formic acid. The main reaction in the subsequent stages involves the formation of peroxides and their oxidation products. The heat of activation of the reaction is 8700 calories per gram molecule. The indications are that the reactions occurring during the induction period are heterogeneous. The subsequent reaction occurs by a chain mechanism. The chains are initiated at the walls of the reaction vessel, and are also largely broken at the walls.


1987 ◽  
Vol 4 (3) ◽  
pp. 339-343 ◽  
Author(s):  
K Kawasaki ◽  
K Sekimoto
Keyword(s):  

1930 ◽  
Vol 3 (4) ◽  
pp. 659-667
Author(s):  
G. R. Boggs ◽  
J. T. Blake

Abstract A new theory has been advanced which, it is believed, explains completely the various phenomena connected with the vulcanization of rubber. It is entirely a chemical theory based on the existence of two separate and distinct rubber compounds, soft vulcanized rubber and ebonite. The theory explains satisfactorily the aging of rubber, the variation in combined sulfur at optimum cure caused by acceleration, the kinetics of vulcanization, the characteristics of various vulcanizing agents, the thermochemistry of vulcanization, the electrical properties of rubber, the reclaiming of rubber, and the Joule effect. A brief review and discussion of the phenomena and past theories of vulcanization have also been given.


2014 ◽  
Vol 53 (24) ◽  
pp. 12757-12766 ◽  
Author(s):  
Michal Strach ◽  
Renaud C. Belin ◽  
Jean-Christophe Richaud ◽  
Jacques Rogez

2012 ◽  
Vol 706-709 ◽  
pp. 149-156 ◽  
Author(s):  
Paulo Rangel Rios ◽  
Elena Villa ◽  
Simone C. de Oliveira

In a recent work, the present authors developed a new formal kinetics methodology suitablefor the situation in which transformations take place simultaneously or sequentially. In this work themain results of such a methodology are briefly presented in a simplified form. It is shown here howthis new methodology may be used for obtaining expressions for simultaneous or sequential reactionsfrom models of the kinetics of each reaction in isolation. It is also shown how one may extract theo-retical information from the experimentally measured quantities. Moreover, the methodology is usedto analyse published data on the recrystallization kinetics of IF steels.


Blood ◽  
2010 ◽  
Vol 116 (21) ◽  
pp. 2921-2921
Author(s):  
Paraskevi Miltiades ◽  
Irene Bouchliou ◽  
Evangelia Nakou ◽  
Emmanuil Spanoudakis ◽  
Sotirios Papageorgiou ◽  
...  

Abstract Abstract 2921 STAT3 and STAT5 regulate fundamental cellular processes and comprise the most studied signaling molecules of both normal and malignant hematopoiesis. Deregulation of STAT signaling contributes to leukemogenesis and may serve as a treatment target. In leukemic progenitors (LPs), the clustering of STAT3 and STAT5 phosphorylation patterns, both basal and after growth factor stimulation, can be achieved by flow cytometry, leading to the identification of distinct signaling profiles (SPs). In acute myeloid leukemia patients, SPs reflect the biological behavior of the LPs and can distinguish patient subgroups with worse prognosis and/or resistance to treatment. As epigenetic defects of genes involved in cell signaling are frequently observed in cancer cells we investigated the alterations in the SPs of MDS progenitors during azacytidine treatment and their correlation with response, cytogenetics and transfusion requirements. Bone marrow samples of 24 high risk MDS patients were obtained before and 15 days after the initiation of azacytidine in order to assess potential changes in SP before the disappearance of the LPs. According to the IWG response criteria patients were divided into group A (CR, PR and HI, n=10) and group B (stable disease and failure, n=14). Immunomagnetically purified LPs were either left untreated or stimulated with G-CSF and GM-CSF for 15` and then stained intracellularly with monoclonal antibodies against STAT3 and STAT5. The comparisons of basal and potentiated responses before and 15 days after azacytidine initiation were made with Mann-Whitney U-test. Clustering of SPs was performed with hierarchical cluster analysis and was correlated with treatment response, cytogenetics and transfusion dependence by using Chi square or Fisher Exact tests as appropriate. All analyses were performed using SPSS 14.0 software (SPSS Science, Chicago, IL). By clustering the SPs before and 15 days after the initiation of azacytidine we distinguished two subgroups of patients based on both the basal levels and potentiated response to growth factors. Patients with generally weak expression of STAT3 and STAT5 had significantly better response to azacytidine compared to those with strong expression of the same molecules (p=0.035), whereas there were no correlation of SPs with the karyotype (p=0.45) and transfusion rate (p=0.39). In line with the above, we further identified a STAT3+STAT5+ double positive population of MDS progenitors whose pretreatment levels after G-CSF and GM-CSF stimulation were inversely associated with treatment response (figure 1). Additionally, SP kinetics were following the disease course and response to therapy. In two late-stage MDS patients who achieved complete remission the SP was restored to early-stage MDS levels in day 15 after azacytidine initiation (figure 2A). In contrast, the SPs in the majority of non-responding patients remained unaltered (figure 2B), whereas the SP of a relapsing patient reverted to pretreatment levels after an initial restoration to early-stage MDS levels (figure 3). Figure 1. Significantly lower pretreatment levels of STAT3+STAT5+ MDS progenitors after G and GM-CSF stimulation in responding patients. (A) Representative plots of a patient who failed azacytidine (i, ii) and one who achieved CR (iii, iv). (B) Cumulative results in responding (A) and non-responding (B) patients. Figure 1. Significantly lower pretreatment levels of STAT3+STAT5+ MDS progenitors after G and GM-CSF stimulation in responding patients. . / (A) Representative plots of a patient who failed azacytidine (i, ii) and one who achieved CR (iii, iv). (B) Cumulative results in responding (A) and non-responding (B) patients. Figure 2. The kinetics of SPs follow the response to azacytidine. (A) The SP of a late-stage MDS patient who attained PR reverted to early-stage MDS levels at day 15 after the first cycle of azacytidine. (B) By contrast, a patient who failed treatment displayed no SP changes. Figure 2. The kinetics of SPs follow the response to azacytidine. . / (A) The SP of a late-stage MDS patient who attained PR reverted to early-stage MDS levels at day 15 after the first cycle of azacytidine. (B) By contrast, a patient who failed treatment displayed no SP changes. Figure 3. Kinetics of the SP in a relapsing patient Plots of a patient who achieved CR but relapsed 4 months after the discontinuation of azacytidine. Figure 3. Kinetics of the SP in a relapsing patient . / Plots of a patient who achieved CR but relapsed 4 months after the discontinuation of azacytidine. In conclusion, we demonstrate that SP alterations of MDS progenitors during azacytidine treatment can predict clinical response. Moreover, it appears that azacytidine can restore the leukemic signaling in MDS by modifying both the basal and potentiated expression of STAT3 and STAT5. Our findings advocate the differentiating activity of hypomethylating agents, potentially via epigenetic reprogramming of pivotal signaling networks of leukemic progenitors. Disclosures: No relevant conflicts of interest to declare.


1986 ◽  
Vol 87 (6) ◽  
pp. 907-932 ◽  
Author(s):  
J H Caldwell ◽  
D T Campbell ◽  
K G Beam

The loose patch voltage clamp has been used to map Na current density along the length of snake and rat skeletal muscle fibers. Na currents have been recorded from (a) endplate membrane exposed by removal of the nerve terminal, (b) membrane near the endplate, (c) extrajunctional membrane far from both the endplate and the tendon, and (d) membrane near the tendon. Na current densities recorded directly on the endplate were extremely high, exceeding 400 mA/cm2 in some patches. The membrane adjacent to the endplate has a current density about fivefold lower than that of the endplate, but about fivefold higher than the membrane 100-200 micron from the endplate. Small local variations in Na current density are recorded in extrajunctional membrane. A sharp decrease in Na current density occurs over the last few hundred micrometers from the tendon. We tested the ability of tetrodotoxin to block Na current in regions close to and far from the endplate and found no evidence for toxin-resistant channels in either region. There was also no obvious difference in the kinetics of Na current in the two regions. On the basis of the Na current densities measured with the loose patch clamp, we conclude that Na channels are abundant in the endplate and near-endplate membrane and are sparse close to the tendon. The current density at the endplate is two to three orders of magnitude higher than at the tendon.


Sign in / Sign up

Export Citation Format

Share Document