scholarly journals Optimization of Biogas Production in a Batch Laboratory Digester Using Total Solids, Substrate Retention Time, and Mesophilic Temperature

2020 ◽  
Vol 4 (2) ◽  
Author(s):  
Barasa H. Masinde ◽  
◽  
Daudi M. Nyaanga ◽  
Musa R. Njue ◽  
Joseph W. Matofari ◽  
...  
Keyword(s):  
Retention Time ◽  
Biogas Production ◽  
Total Solids ◽  
Mesophilic Temperature

scholarly journals Anaerobic biodigestion of pigs feces in the initial, growing and finishing stages fed with diets formulated with corn or sorghum

2012 ◽  
Vol 32 (1) ◽  
pp. 47-56 ◽  
Author(s):  
Adélia P. Miranda ◽  
Jorge de Lucas Junior ◽  
Maria C. Thomaz ◽  
Gener T. Pereira ◽  
Ellen H. Fukayama
Keyword(s):  
Retention Time ◽  
Hydraulic Retention Time ◽  
Biogas Production ◽  
Average Content ◽  
Total Solids ◽  
Volatile Solids ◽  
Zn And Cu In ◽  
The Mean

The objective of this study was to evaluate the quality and the production of biogas and biofertilizer obtained from biodigester supplied with pig feces in the initial, growing and finishing stages, fed with diets formulated based on corn or sorghum. Twenty bench biodigesters were used with hydraulic retention time of 30 days and daily loads that contained 4 to 6% of total solids (TS) and 3.6 to 5.2% of volatile solids (VS). In the effluent of the biodigesters, mean levels of TS were observed ranging between 1.6 and 2.0% and of VS between 1.2 and 1.6%. The mean reductions of TS were 57.7 to 64.7% and of VS from 61.7 to 69.0%, and there was only difference in the finishing phase, in which the major averages reductions were produced by the biodigesters supplied with feces from animals fed with diets based on corn. In biodigesters supplied with feces from animals in the initial and growing stages fed with diets based on corn, were observed higher average productions of biogas and the greatest average potentials of biogas production. The average potentials obtained were 0.033; 0.181; 0.685; 0.788 and 1.132 m³ per kg of affluent, manure, TS added, VS added and VS reduced, respectively. No differences were found on the average content of methane in the biogas between diets and stages. The average concentrations of nutrients N, P, K, Ca, Mg, Na, Fe, Mn, Zn and Cu in the biodigester affluent and effluent, ranged between diets and stages.

scholarly journals Effect of Total Solids on Biogas Production in a Fixed Dome Laboratory Digester under Mesophilic Temperature

2020 ◽  
Vol 4 (2) ◽  
Author(s):  
Barasa H. Masinde ◽  
◽  
Daudi M. Nyaanga ◽  
Musa R. Njue ◽  
Joseph W. Matofari ◽  
...  
Keyword(s):  
Biogas Production ◽  
Total Solids ◽  
Mesophilic Temperature

Anaerobic thermophilic digestion of sewage sludge with a thickened sludge recycle

2012 ◽  
Vol 65 (3) ◽  
pp. 403-409 ◽  
Author(s):  
A. Ya. Vanyushina ◽  
Yu. A. Nikolaev ◽  
A. M. Agarev ◽  
M. V. Kevbrina ◽  
M. N. Kozlov
Keyword(s):  
Retention Time ◽  
Municipal Wastewater ◽  
Hydraulic Retention Time ◽  
Biogas Production ◽  
Wastewater Sludge ◽  
Recycling Process ◽  
Digested Sludge ◽  
Volatile Solids ◽  
Solids Retention ◽  
Thermophilic Digestion

The process of anaerobic thermophilic digestion of municipal wastewater sludge with a recycled part of thickened digested sludge, was studied in semi-continuous laboratory digesters. This modified recycling process resulted in increased solids retention time (SRT) with the same hydraulic retention time (HRT) as compared with traditional digestion without recycling. Increased SRT without increasing of HRT resulted in the enhancement of volatile substance reduction by up to 68% in the reactor with the recycling process compared with 34% in a control conventional reactor. Biogas production was intensified from 0.3 L/g of influent volatile solids (VS) in the control reactor up to 0.35 L/g VS. In addition, the recycling process improved the dewatering properties of digested sludge.

scholarly journals Influence of manure concentration as inoculum in anaerobic digestion of vinasse

2017 ◽  
Vol 39 (2) ◽  
pp. 173 ◽  
Author(s):  
Carlos Eduardo de Farias Silva ◽  
Ana Karla de Souza Abud
Keyword(s):  
Biological Process ◽  
Biogas Production ◽  
Oxygen Demand ◽  
Microbiological Analysis ◽  
Total Solids ◽  
Major Factors ◽  
Nitrogen Contents ◽  
Subsequent Stabilization ◽  
Microbial Action ◽  
Sugarcane Industry

Vinasse, main residue of the sugarcane industry, has high pollutant content, being subjected to the use in biogas production due to the high content of organic matter non-toxic to microbial action. For a consolidated process, it is necessary to study parameters that influence the process, in which the amount of inoculum is one of the major factors in the biological process of biogas production. This study investigated the influence of the amount of manure as inoculum (0.5 to 5.5%) during the biodigestion process, evaluating variables such as chemical oxygen demand (COD), pH, biogas production, methane concentration, total solids and total phosphorus and nitrogen contents, as well as microbiological analysis in the sludge remaining in the digester. Biodigestion occurred normally, with hydraulic retention time (HRT) of 20 days, with an acidogenic phase, subsequent stabilization of pH and biogas production. The vinasse had COD and total solids reduced during biodigestion by around 67 and 40%, respectively. Biogas production was increased after the fifth day. Among the three studied conditions, there was no significant increase in efficiency of inoculum use and it can be used the lowest amount, 0.5 % (m v-1). 

scholarly journals Effect of Hydraulic Retention Time on Biogas Production from Cow Dung in A Semi Continuous Anaerobic Digester

2018 ◽  
Vol 7 (2) ◽  
pp. 93-100 ◽  
Author(s):  
Agus Haryanto ◽  
Sugeng Triyono ◽  
Nugroho Hargo Wicaksono
Keyword(s):  
Retention Time ◽  
Hydraulic Retention Time ◽  
Loading Rate ◽  
Biogas Production ◽  
Stable Condition ◽  
Anaerobic Digester ◽  
Organic Loading Rate ◽  
Cow Dung ◽  
Biogas Yield ◽  
Average Analysis

The efficiency of biogas production in semi-continuous anaerobic digester is influenced by several factors, among other is loading rate. This research aimed at determining the effect of hydraulic retention time (HRT) on the biogas yield. Experiment was conducted using lab scale self-designed anaerobic digester of 36-L capacity with substrate of a mixture of fresh cow dung and water at a ratio of 1:1. Experiment was run with substrate initial amount of 25 L and five treatment variations of HRT, namely 1.31 gVS/L/d (P1), 2.47 gVS/L/d (P2), 3.82 gVS/L/d (P3), 5.35 gVS/L/d (P4) and 6.67 gVS/L/d (P5). Digester performance including pH, temperature, and biogas yield was measured every day. After stable condition was achieved, biogas composition was analyzed using a gas chromatograph. A 10-day moving average analysis of biogas production was performed to compare biogas yield of each treatment. Results showed that digesters run quite well with average pH of 6.8-7.0 and average daily temperature 28.7-29.1. The best biogas productivity (77.32 L/kg VSremoval) was found in P1 treatment (organic loading rate of 1.31 g/L/d) with biogas yield of 7.23 L/d. With methane content of 57.23% treatment P1 also produce the highest methane yield. Biogas production showed a stable rate after the day of 44. Modified Gompertz kinetic equation is suitable to model daily biogas yield as a function of digestion time.Article History: Received March 24th 2018; Received in revised form June 2nd 2018; Accepted June 16th 2018; Available onlineHow to Cite This Article: Haryanto, A., Triyono, S., and Wicaksono, N.H. (2018) Effect of Loading Rate on Biogas Production from Cow Dung in A Semi Continuous Anaerobic Digester. Int. Journal of Renewable Energy Development, 7(2), 93-100.https://doi.org/10.14710/ijred.7.2.93-100

Optimum Mesophilic Temperature of Biogas Production from Blends of Agro-Based Wastes

2007 ◽  
Vol 2 (1) ◽  
pp. 39-44 ◽  
Author(s):  
E.O.U. Uzodinma . ◽  
A.U. Ofoefule . ◽  
J.I. Eze . ◽  
N.D. Onwuka .
Keyword(s):  
Biogas Production ◽  
Mesophilic Temperature

Treatment of a chocolate industry wastewater in a pilot-scale low-temperature UASB reactor operated at short hydraulic and sludge retention time

2013 ◽  
Vol 67 (6) ◽  
pp. 1353-1361 ◽  
Author(s):  
M. Esparza-Soto ◽  
O. Arzate-Archundia ◽  
C. Solís-Morelos ◽  
C. Fall
Keyword(s):  
Low Temperature ◽  
Retention Time ◽  
Biogas Production ◽  
Pilot Scale ◽  
Uasb Reactor ◽  
Organic Loading Rate ◽  
Anaerobic Sludge ◽  
Processing Industry ◽  
Sludge Retention Time ◽  
Industry Wastewater

The aim of this work was to evaluate the performance of a 244-L pilot-scale upflow anaerobic sludge blanket (UASB) reactor during the treatment of chocolate-processing industry wastewater under low-temperature conditions (18 ± 0.6 °C) for approximately 250 d. The applied organic loading rate (OLR) was varied between 4 and 7 kg/m3/d by varying the influent soluble chemical oxygen demand (CODsol), while keeping the hydraulic retention time constant (6.4 ± 0.3 h). The CODsol removal efficiency was low (59–78%). The measured biogas production increased from 240 ± 54 to 431 ± 61 L/d during the experiments. A significant linear correlation between the measured biogas production and removed OLR indicated that 81.69 L of biogas were produced per kg/m3 of CODsol removed. Low average reactor volatile suspended solids (VSS) (2,700–4,800 mg/L) and high effluent VSS (177–313 mg/L) were derived in a short sludge retention time (SRT) (4.9 d). The calculated SRT was shorter than those reported in the literature, but did not affect the reactor's performance. Average sludge yield was 0.20 kg-VSS/kg-CODsol. The low-temperature anaerobic treatment was a good option for the pre-treatment of chocolate-processing industry wastewater.

Sign in / Sign up

Export Citation Format

Share Document