scholarly journals The Effect of Temperature on Extraction of Swietenia Mahagoni by Ultrasound–assisted Extraction (UAE) Method

2016 ◽  
Vol 16 (1) ◽  
pp. 45 ◽  
Author(s):  
Ike Dayi Febriana ◽  
Heri Septya Kusuma ◽  
Selfina Galan ◽  
Mahfud Mahfud
Keyword(s):  
Azo Dyes ◽  
Organic Dyes ◽  
Natural Dye ◽  
Raw Material ◽  
Effect Of Temperature ◽  
Extraction Temperature ◽  
Ultrasound Assisted Extraction ◽  
Assisted Extraction ◽  
Ultrasound Assisted ◽  
Swietenia Mahagoni

Azo dyes are synthetic organic dyes which have azo group (-N=N-) as chromophore. Waste of azo dyes have not been able to overcome completely so that requires solutions of natural dye. Raw material of natural dye can be obtained from Swietenia mahagoni. Natural dye can be extracted by ultrasound-assisted extraction (UAE) method. The pupose of this research is to study the factor that influence UAE. Observed factor is influence of extraction temperature to the yield of natural dye. This research was conducted using ratio of material to solvent of 0.05 g/L with extraction time at 40 minute. Extraction temperature was observed at 30, 40, and 50oC. Ultrasonic wave that used for this research at 40 kHz. The result is increasing temperature will be allow the increasing trend of yield. The result indicate that there is about 9.2748% improvement in the yield of extract due to increasing extraction temperature from 30oC to 50oC

scholarly journals Optimization of an Ultrasound-Assisted Extraction Method for the Analysis of Major Anthocyanin Content in Erica australis Flowers

Molecules ◽  
2021 ◽  
Vol 26 (10) ◽  
pp. 2884
Author(s):  
Ceferino Carrera ◽  
María José Aliaño-González ◽  
Jaime Rodríguez-López ◽  
Marta Ferreiro-González ◽  
Fernando Ojeda-Copete ◽  
...  
Keyword(s):  
Folk Medicine ◽  
Anthocyanin Content ◽  
Extraction Temperature ◽  
Ultrasound Assisted Extraction ◽  
Assisted Extraction ◽  
Relative Standard ◽  
Precision Study ◽  
Ultrasound Assisted ◽  
Ph Level ◽  
Erica Australis

Erica australis plants have been used in infusions and folk medicine for years for its diuretic and antiseptic properties and even for the treatment of infections. In addition, a recently published thorough study on this species has demonstrated its antioxidant, antibiotic, anti-inflammatory, anticarcinogenic and even antitumoral activities. These properties have been associated with the high content of anthocyanins in E. australis leaves and flowers. The aim of the present research is to optimize an ultrasound-assisted extraction methodology for the recovery of the anthocyanins present in E. australis flowers. For that purpose, a Box Behnken design with response surface methodology was employed, and the influence of four variables at different values was determined: namely, the composition of the extraction solvents (0–50% MeOH in water), the pH level of those solvents (3–7), the extraction temperature (10–70 °C), and the sample:solvent ratio (0.5 g:10 mL–0.5 g:20 mL). UHPLC-UV-vis has been employed to quantify the two major anthocyanins detected in the samples. The extraction optimum conditions for 0.5 g samples were: 20 mL of solvent (50% MeOH:H2O) at 5 pH, with a 15 min extraction time at 70 °C. A precision study was performed and the intra-day and inter-day relative standard deviations (RSDs) obtained were 3.31% and 3.52%, respectively. The developed methodology has been successfully applied to other Erica species to validate the suitability of the method for anthocyanin extraction.

scholarly journals Skin-Whitening and Anti-Wrinkle Effects of Bioactive Compounds Isolated from Peanut Shell Using Ultrasound-Assisted Extraction

Molecules ◽  
2021 ◽  
Vol 26 (5) ◽  
pp. 1231
Author(s):  
Da Hye Gam ◽  
Ji Woo Hong ◽  
Jun Hee Kim ◽  
Jin Woo Kim
Keyword(s):  
Ethanol Concentration ◽  
Extraction Time ◽  
Extraction Temperature ◽  
Peanut Shell ◽  
Ultrasound Assisted Extraction ◽  
Skin Whitening ◽  
Activity Inhibition ◽  
Assisted Extraction ◽  
Ultrasound Assisted ◽  
Experimental Values

Response surface methodology was employed to optimize the ultrasound-assisted extraction (UAE) conditions for simultaneous optimization of dependent variables, including DPPH radical scavenging activity (RSA), tyrosinase activity inhibition (TAI), and collagenase activity inhibition (CAI) of peanut shell extracts. The effects of the main variables including extraction time (5.0~55.0 min, X1), extraction temperature (26.0~94.0 °C, X2), and ethanol concentration (0.0%~99.5%, X3) were optimized. Based on experimental values from each condition, quadratic regression models were derived for the prediction of optimum conditions. The coefficient of determination (R2) of the independent variable was in the range of 0.89~0.96, which demonstrates that the regression model is suitable for the prediction. In predicting optimal UAE conditions based on the superimposing method, extraction time of 31.2 min, extraction temperature of 36.6 °C, and ethanol concentration of 93.2% were identified. Under these conditions, RSA of 74.9%, TAI of 50.6%, and CAI of 86.8% were predicted, showing good agreement with the experimental values. A reverse transcription polymerase chain reaction showed that peanut shell extract decreased mRNA levels of tyrosinase-related protein-1 and matrix metalloproteinase-3 genes in B16-F0 cell. Therefore, we identified the skin-whitening and anti-wrinkle effects of peanut shell extracts at protein as well as gene expression levels, and the results show that peanut shell is an effective cosmetic material for skin-whitening and anti-wrinkle effects. Based on this study, peanut shell, which was considered a byproduct, can be used for the development of healthy foods, medicines, and cosmetics.

scholarly journals Quantitative Evaluation of Ultrasound-Assisted Extraction of 1,3-β-glucans from Dictyophora indusiata Using an Improved Fluorometric Assay

Polymers ◽  
2019 ◽  
Vol 11 (5) ◽  
pp. 864 ◽  
Author(s):  
Yuan Fu ◽  
Shang Lin ◽  
Min Lu ◽  
Si-Yu Wei ◽  
Jia Zhou ◽  
...  
Keyword(s):  
Quantitative Evaluation ◽  
Water Soluble ◽  
Fluorometric Assay ◽  
Edible Mushrooms ◽  
Raw Material ◽  
Blue Dye ◽  
Improved Method ◽  
Ultrasound Assisted Extraction ◽  
Assisted Extraction ◽  
Ultrasound Assisted

In the present study, an improved fluorometric assay based on aniline blue dye for the specific, accurate, and rapid quantification of 1,3-β-glucans in edible mushrooms was developed and fully validated. Furthermore, the improved method was successfully applied for the quantitative evaluation of water soluble 1,3-β-glucans extracted from Dictyophora indusiata by ultrasound-assisted extraction (UAE) with response surface methodology. Results showed that the improved method exhibited high specificity, accuracy, precision, repeatability, and stability, as well as a wide calibration range of 10–600 µg/mL (R2 > 99.9%). The maximum extraction yields of water soluble 1,3-β-glucans (1.20%) and total polysaccharides (5.41%) were achieved at the optimized extraction parameters as follows: ultrasound amplitude (56%), ultrasound extraction time (15 min), and ratio of liquid to raw material (22 mL/g). The results suggest that the improved fluorometric assay has great potential to be used as a routine method for the quantitative evaluation of 1,3-β-glucans in edible mushrooms and that the UAE method is effective for the extraction of 1,3-β-glucans from edible mushrooms.

scholarly journals Optimization of Ultrasound-Assisted Extraction of Antioxidant Polyphenols from the Seed Coats of Red Sword Bean (Canavalia gladiate (Jacq.) DC.)

Antioxidants ◽  
2019 ◽  
Vol 8 (7) ◽  
pp. 200 ◽  
Author(s):  
Yue Zhou ◽  
Xiao-Yu Xu ◽  
Ren-You Gan ◽  
Jie Zheng ◽  
Ya Li ◽  
...  
Keyword(s):  
Extraction Method ◽  
Natural Antioxidants ◽  
Extraction Time ◽  
Antioxidant Compounds ◽  
Extraction Temperature ◽  
Ultrasound Assisted Extraction ◽  
Solid Ratio ◽  
Assisted Extraction ◽  
Ultrasound Assisted ◽  
Seed Coats

The seed coat of red sword bean (Canavalia gladiata (Jacq.) DC.) is rich in antioxidant polyphenols. It is often discarded as a byproduct with the consumption of red sword bean, since it is very thick and not consumed by people. The aim of this study was to develop an ultrasound-assisted extraction method to extract natural antioxidants from the seed coats. The extraction process was optimized by using response surface methodology. After the single-factor experiments, three key factors, including ethanol concentration, liquid/solid ratio, and extraction time, were selected and their interactions were studied using a central composite design. The optimal extraction condition was 60.2% hydroethanol, a liquid/solid ratio of 29.3 mL/g, an extraction time of 18.4 min, an extraction temperature of 50 °C, and ultrasound power of 400 W. Under the optimal conditions, antioxidant activity of the extract was 755.98 ± 10.23 μmol Trolox/g dry weight (DW), much higher than that from maceration (558.77 ± 14.42 μmol Trolox/g DW) or Soxhlet extraction (479.81 ± 12.75 μmol Trolox/g DW). In addition, the main antioxidant compounds in the extract were identified and quantified by high-performance liquid chromatography–diode array detection–tandem mass spectrometry (HPLC–DAD–MS/MS). The concentrations of digalloyl hexoside, methyl gallate, gallic acid, trigalloyl hexoside, and digallic acid were 15.30 ± 0.98, 8.85 ± 0.51, 8.76 ± 0.36, 4.27 ± 0.21, and 2.89 ± 0.13 mg/g DW. This study provides an efficient and green extraction method for the extraction of natural antioxidants from the bean coat of red sword bean. The extract of antioxidants might be added into functional foods or nutraceuticals with potential beneficial functions.

scholarly journals Ultrasound-Assisted Extraction of Total Acetogenins from the Soursop Fruit by Response Surface Methodology

Molecules ◽  
2020 ◽  
Vol 25 (5) ◽  
pp. 1139 ◽  
Author(s):  
Gabriela Aguilar-Hernández ◽  
María de los Ángeles Vivar-Vera ◽  
María de Lourdes García-Magaña ◽  
Napoleón González-Silva ◽  
Alejandro Pérez-Larios ◽  
...  
Keyword(s):  
Response Surface Methodology ◽  
Response Surface ◽  
Large Scale ◽  
Raw Material ◽  
Ultrasound Assisted Extraction ◽  
Fruit Peel ◽  
Optimal Method ◽  
Assisted Extraction ◽  
Ultrasound Assisted ◽  
By Products

The soursop fruit or Annona muricata (A. muricata) fruit is recognized by its bioactive compounds and acetogenins (ACG) are among the most important. The effect of ACGs, with greater importance in health, is that they present anti-tumor activity; however, the methods of extraction of ACGs are very slow and with a high expenditure of solvents. To our knowledge, there is no report of an optimal method for the extraction of acetogenins from the Annonaceae family by ultrasound-assisted extraction (UAE); therefore, the aim was to find the best UEA conditions of acetogenins from A. muricata fruit (peel, pulp, seed, and columella) by using response surface methodology. The effect of amplitude (40%, 70%, and 100%), time (5, 10, and 15 min), and pulse-cycle (0.4, 0.7, and 1 s) of ultrasound at 24 kHz was evaluated on the total acetogenin content (TAC). Optimal extraction conditions of acetogenins (ACGs) with UEA were compared with the extraction of ACGs by maceration. The optimal UEA conditions in the A. muricata pulp and by-products were dependent on each raw material. The highest TAC was found in the seed (13.01 mg/g dry weight (DW)), followed by the peel (1.69 mg/g DW), the pulp (1.67 mg/g DW), and columella (1.52 mg/g DW). The experimental TAC correlated well with the model (Adjusted R2 with values between 0.88 and 0.97). The highest effectiveness in ACG extraction was obtained in seeds and peels using UEA compared to extraction by maceration (993% and 650%, respectively). The results showed that A. muricata by-products are an important source of ACGs and that UAE could be a viable alternative, with high potential for large-scale extraction.

Process Optimization of Ultrasound-Assisted Extraction of Pectin from Helianthus annuus L. Heads by Response Surface Methodology

2014 ◽  
Vol 955-959 ◽  
pp. 848-854
Author(s):  
Yin Xiang Gao ◽  
Lei Yang ◽  
Yuan Gang Zu ◽  
Li Ping Yao
Keyword(s):  
Response Surface Methodology ◽  
Response Surface ◽  
Helianthus Annuus ◽  
Response Surfaces ◽  
Quadratic Model ◽  
High Yield ◽  
Extraction Temperature ◽  
Ultrasound Assisted Extraction ◽  
Assisted Extraction ◽  
Ultrasound Assisted

An ultrasound-assisted procedure for the extraction of pectin from heads ofHelianthus annuusL. (sunflower) was established. A Box–Behnken design (BBD) was employed to optimize the extraction temperature (X1: 30–50°C), extraction time (X2: 20–40 min) and pH (X3: 2.5–3.5) to obtain a high yield of pectin with high degree of esterification (DE) from sunflower heads. Analysis of variance showed that the contribution of a quadratic model was significant for the pectin extraction yield and DE. An optimization study using response surface methodology was performed and 3D response surfaces were plotted from the mathematical model. According to the RSM model, the highest pectin yield (23.11 ± 0.08%) and DE (39.85 ± 0.14%) can be achieved when the UAE process is carried out at 50°C for 40min using a hydrochloric acid solution of pH 3.0. These results suggest that ultrasound-assisted extraction could be a good option for the extraction of functional pectin from sunflower heads at industrial level.

scholarly journals Extraction and Determination of Vitamin K1 in Foods by Ultrasound-Assisted Extraction, SPE, and LC-MS/MS

Molecules ◽  
2020 ◽  
Vol 25 (4) ◽  
pp. 839 ◽  
Author(s):  
Yueqing Xu ◽  
Liangxiao Zhang ◽  
Ruinan Yang ◽  
Xu Yu ◽  
Li Yu ◽  
...  
Keyword(s):  
Formic Acid ◽  
Limit Of Detection ◽  
Solid Phase ◽  
Extraction Temperature ◽  
Vitamin K1 ◽  
Ultrasound Assisted Extraction ◽  
Limit Of Quantification ◽  
Assisted Extraction ◽  
Ultrasound Assisted

Vitamin K1 is one of the important hydrophobic vitamins in fat-containing foods. Traditionally, lipase is employed in the determination of vitamin K1 to remove the lipids, which makes the detection complex, time-consuming, and insensitive. In this study, the determination of vitamin K1 in fat-containing foods was developed based on ultrasound-assisted extraction (UAE), solid-phase extraction (SPE) combined with liquid chromatography–tandem mass spectrometry (LC-MS/MS). The optimal conditions for extraction of vitamin K1 were material–liquid ratio of 1:70 (g/mL), extraction temperature of 50 °C, extraction power of 700 W, extraction time of 50 min, material-wash fluid ratio of 1:60 (g/mL), and 8 mL of hexane/anhydrous ether (97:3, v/v) as the elution solvent. Then, vitamin K1 was analyzed on a ZORBAX SB-C18 column (50 mm × 2.1 mm, 1.8 μm) by gradient elution with water (0.01% formic acid) and methanol (0.01 formic acid + 2.5 mmol/L ammonium formate) as the mobile phase. The limit of detection (LOD) and limit of quantification (LOQ) were 0.05 and 0.16 μg/kg, respectively. Calibration curve was linear over the range of 10–500 ng/mL (R2 > 0.9988). The recoveries at three spiked levels were between 80.9% and 119.1%. The validation and application indicated that the proposed method was simple and sensitive in determination of vitamin K1 in fat-containing foods.

scholarly journals Chemical composition of dried Stevia rebaudiana Bertoni leaves and effect of ultrasound-assisted extraction on total steviosides content in extract

2021 ◽  
Vol 67 (1) ◽  
pp. 1-7
Author(s):  
Nguyen Thi Hoang Yen ◽  
Le Pham Tan Quoc
Keyword(s):  
Colorimetric Assay ◽  
Stevia Rebaudiana ◽  
Extraction Time ◽  
Chemical Compositions ◽  
Solvent Ratio ◽  
Extraction Temperature ◽  
Ultrasound Assisted Extraction ◽  
Assisted Extraction ◽  
Ultrasound Assisted ◽  
Major Chemical

Summary Introduction: Steviol stevioside, which has been used in the production of food products as a low-calorie sweeten, is one of the main glycoside groups in the leaves of the Stevia plants. It is useful for human health. Objective: The main objection of the present study was to find out some major chemical compositions of the dried Stevia rebaudiana Bertoni leaves and an effective, affordable, and environmentally friendly method to reach the high extraction yield of total steviosides from them. Therefore, a novel extraction, ultrasound-assisted extraction (UAE), was carried out to extract total steviosides from dried leaves of S. rebaudiana plant with ethanol of 70% (v/v) as a solvent. Methods: Some major chemical compositions of the dried S. rebaudiana leaves were analyzed according to the AOAC (Association of Official Analytical Chemists) and total steviosides content (TSC) was measured by anthrone-sulphuric acid colorimetric assay with main influencing factors including material/solvent ratio, extraction temperature, and extraction time. Results: The results referred that some chemical compounds such as protein, lipid, fibre, sugar, etc. existed in this material. The best extraction conditions were the sample/solvent ratio of 1:100 (g/ml), extraction temperature of 75oC, and extraction time of 30 min. Conclusion: The highest amount of total steviosides content of 8.894 % was obtained at the optimal extraction condition. Consequently, these results demonstrated that the parameters of UAE were applied successfully for producing total glycosides.

scholarly journals Response Surface Optimization of a Rapid Ultrasound-Assisted Extraction Method for Simultaneous Determination of Tetracycline Antibiotics in Manure

2015 ◽  
Vol 2015 ◽  
pp. 1-10 ◽  
Author(s):  
Lanqing Li ◽  
Mingxing Sun ◽  
Hui Zhou ◽  
Yun Zhou ◽  
Ping Chen ◽  
...  
Keyword(s):  
Response Surface ◽  
Extraction Method ◽  
Extraction Procedure ◽  
Extraction Time ◽  
Extraction Temperature ◽  
Ultrasound Assisted Extraction ◽  
Solution Ph ◽  
Assisted Extraction ◽  
Ultrasound Assisted

A rapid and cleanup-free ultrasound-assisted extraction method is proposed for the simultaneous extraction of oxytetracycline, tetracycline, chlortetracycline, and doxycycline in manure. The analytes were determined using high-performance liquid chromatography with ultraviolet detector. The influence of several variables on the efficiency of the extraction procedure was investigated by single-factor experiments. The temperature, pH, and amount of extraction solution were selected for optimization experiment using response surface methodology. The calibration curves showed good linearity (R2>0.99) for all analytes in the range of 0.1–20 μg/mL. The four antibiotics were successfully extracted from manure with recoveries ranging from 81.89 to 92.42% and good reproducibility (RSD, <4.06%) under optimal conditions, which include 50 mL of McIlvaine buffer extraction solution (pH 7.15) mixed with 1 g of manure sample, extraction temperature of 40°C, extraction time of 10 min, and three extraction cycles. Method quantification limits of 1.75–2.32 mg/kg were obtained for the studied compounds. The proposed procedure demonstrated clear reductions in extraction time and elimination of cleanup steps. Finally, the applicability to tetracyclines antibiotics determination in real samples was evaluated through the successful determination of four target analytes in swine, cow manure, and mixture of animal manure with inorganic fertilizer.

scholarly journals Optimization of Ultrasound-Assisted Extraction of Phenolic Compounds from Annona muricata By-Products and Pulp

Molecules ◽  
2019 ◽  
Vol 24 (5) ◽  
pp. 904 ◽  
Author(s):  
Gabriela Aguilar-Hernández ◽  
María García-Magaña ◽  
María Vivar-Vera ◽  
Sonia Sáyago-Ayerdi ◽  
Jorge Sánchez-Burgos ◽  
...  
Keyword(s):  
Phenolic Compounds ◽  
Bioactive Compounds ◽  
Raw Materials ◽  
Raw Material ◽  
Ultrasound Assisted Extraction ◽  
Total Polyphenols ◽  
Assisted Extraction ◽  
Ultrasound Assisted ◽  
Conventional Extraction ◽  
By Products

Ultrasound-assisted extraction (UAE) is widely used; however, the efficiency of extraction depends on the raw materials. Therefore, optimization of UAE must be investigated for each type of plant material. By-products from soursop fruit have not been studied as a source of bioactive compounds. In this work, the optimization of UAE conditions (extraction time (5, 10, and 15 min), pulse cycle (0.4, 0.7, and 1 s), and sonication amplitude (40%, 70%, and 100%)) for the extraction of phenolic compounds (soluble, hydrolyzable, condensed tannins, and total polyphenols) from soursop by-products (seed, peel, and columella) and pulp was evaluated using response surface methodology. The optimal conditions for UAE to obtain the highest total polyphenol content from by-products and pulp was dependent on the raw material. Peel resulted in the highest content of total polyphenols (187.32 mg/g dry matter [DM]) followed by columella (164.14 mg/g DM), seed (36.15 mg/g DM), and pulp (33.24 mg/g DM). The yield of polyphenolic content from peel and columella obtained with UAE was higher (32–37%) than conventional extraction for 2 h under stirring (14–16%). The contents of gallic acid (0.36–15.86 µg/g DM), coumaric acid (0.07–1.37 µg/g DM), and chlorogenic acid (9.18–32.67 µg/g DM) in the different parts of the fruit were higher in the extracts obtained by UAE compared with a conventional extraction method (0.08–0.61, 0.05–0.08, 3.15–13.08 µg/g DM, respectively), although it was dependent on the raw materials. Soursop by-products can be functionally important if they are used to extract bioactive compounds by UAE; a technology with high potential for commercial extraction on a large scale.

Sign in / Sign up

Export Citation Format

Share Document