Application of urea dosing for alkalinity supply during anaerobic digestion of vinasse

2012 ◽  
Vol 66 (11) ◽  
pp. 2453-2460 ◽  
Author(s):  
M. A. Boncz ◽  
E. L. Formagini ◽  
L. da S. Santos ◽  
R. D. Marques ◽  
P. L. Paulo
Keyword(s):  
Anaerobic Digestion ◽  
Power Supply ◽  
Treatment Process ◽  
Ph Regulation ◽  
Anaerobic Treatment ◽  
Ammonia Toxicity ◽  
Hydroelectric Power ◽  
Anaerobic Conditions ◽  
Successful Operation ◽  
Alternative Source

Pushed by demand for renewable energy, the ethanol industry in Brazil is expanding. However, production of 1 m3 of ethanol generates around 13 m3 of liquid residues (vinasse), so this expansion results in an increasing need for a more adequate destination of these residues. Nowadays the vinasse is dispersed on the sugar cane fields in the practice of fertirrigation, but anaerobic digestion of this residue may be a better solution, additionally offering an alternative source of energy, able to complement hydroelectric power supply in the dry season. However, when trying to digest vinasse at reduced hydraulic retention times, complications arise from its strong tendency toward acidification, upsetting the fragile balance of transformations normally occurring under anaerobic conditions. For successful operation of an anaerobic treatment process with acceptable hydraulic residence times, increasing alkalinity levels inside the reactor is neces­sary. In the present work we show that pH regulation by means of urea dosing, in spite of the risk posed by ammonia toxicity towards methanogenic biomass, can be a viable alternative to avoid vinasse acidification. The ammonia formed in urea conversion remains in solution, rather than escaping to the biogas, and so its use as fertiliser can offset its cost of application in the process.

Pond Treatment of Rettery Wastewaters

1987 ◽  
Vol 19 (12) ◽  
pp. 79-83
Author(s):  
K. Bartoszewski ◽  
A. Bilyk
Keyword(s):  
Activated Sludge ◽  
Treatment Process ◽  
New Technology ◽  
Treatment Plant ◽  
Anaerobic Treatment ◽  
Cod Removal ◽  
Experimental Results ◽  
Aerobic Conditions ◽  
Aerobic Stabilization ◽  
In Series

Rettery wastewaters were treated in anaerobic and aerobic ponds. Anaerobic treatment yielded efficiencies of BOD5 and COD removal as low as 20%. The treatment process conducted under aerobic conditions in aerated and stabilizing ponds arranged in series took from 18 to 20 days and gave efficiencies of BOD5 and COD removal amounting to 90%. The experimental results were interpreted by virtue of the Eckenfelder equation. Excess activated sludge was subjected to aerobic stabilization in a separate tank. A new technology was suggested for the existing obsolete industrial treatment plant.

A simple design and operation for the anaerobic treatment of highly concentrated swine waste in the tropics

1995 ◽  
Vol 32 (12) ◽  
pp. 91-97 ◽  
Author(s):  
P. Y. Yang ◽  
M. Kuroshima
Keyword(s):  
Treatment Process ◽  
Total Solid ◽  
Anaerobic Treatment ◽  
Solid Content ◽  
Total Solid Content ◽  
Treatment Processes ◽  
Tropical Conditions ◽  
Biological Reaction ◽  
The Tropics ◽  
Small Producers

In order to develop a simple operation for an anaerobic treatment process for highly concentrated pig wastewater for small producers, a three-stage anaerobic treatment process was investigated. The system provided a series of mixing, homogenization, biological reaction and final stabilization of concentrated pig waste (total solid content of 8–10%). The process provided a stable operational performance, simple operational procedure and well stabilized sludge effluent. It was also found that the system is economically feasible in Hawaii. Compared to the other treatment processes for highly concentrated pig waste, this process is considered as an appropriate alternative for the application of the small producers in land limited and tropical conditions. Also, the present treatment system can be easily developed into a prefabricated package plant which can minimize the on-site labor and building costs.

Anaerobic treatment of soil wash fluids from a wood preserving site

1998 ◽  
Vol 38 (7) ◽  
pp. 63-72 ◽  
Author(s):  
K. M. Miller ◽  
M. T. Suidan ◽  
G. A. Sorial ◽  
A. P. Khodadoust ◽  
C. M. Acheson ◽  
...  
Keyword(s):  
Soil Washing ◽  
Anaerobic Treatment ◽  
Integrated System ◽  
Waste Stream ◽  
Adsorptive Capacity ◽  
Anaerobic Conditions ◽  
Washing Process ◽  
Polycyclic Aromatic ◽  
Treatment Technologies ◽  
Solvent Washing

An integrated system has been developed to remediate soils contaminated with pentachlorophenol (PCP) and polycyclic aromatic hydrocarbons (PAHs). This system involves the coupling of two treatment technologies, soil solvent washing and anaerobic biotreatment of the extract. Specifically, this study evaluated the effectiveness of the granular activated carbon (GAC) fluidized-bed reactor to treat a synthetic waste stream of PCP and four PAHs (naphthalene, acenaphthene, pyrene, and benzo(b)fluoranthene) under anaerobic conditions. This waste stream was intended to simulate the wash fluids from a soil washing process treating soils from a wood preserving site. The reactor achieved a removal efficiency of greater than 99.8% for PCP with conversion to its dechlorination intermediates ranging from 47% to 77%. Effluent, carbon extraction, and isotherm data also indicate that naphthalene and acenaphthene were removed from the liquid phase with efficiencies of 86% and 93%, respectively. Effluent levels of pyrene and benzo(b)fluoranthene were extremely low due to the adsorptive capacity of GAC for these compounds. Experimental evidence does not suggest that these compounds were chemically transformed within the reactor.

Development of a Mainstream Anaerobic Treatment Process Using a Hybrid UASB-Micro Sieve System

2016 ◽  
Vol 2016 (14) ◽  
pp. 2686-2695 ◽  
Author(s):  
Jose A Jimenez ◽  
Lisa Bethke ◽  
Maxime Rattier ◽  
Shihu Hu ◽  
Domenico Santoro ◽  
...  
Keyword(s):  
Treatment Process ◽  
Anaerobic Treatment

scholarly journals Improving the Anaerobic Digestion of Swine Manure through an Optimized Ammonia Treatment: Process Performance, Digestate and Techno-Economic Aspects

Energies ◽  
2021 ◽  
Vol 14 (3) ◽  
pp. 787
Author(s):  
Anna Lymperatou ◽  
Niels B. Rasmussen ◽  
Hariklia N. Gavala ◽  
Ioannis V. Skiadas
Keyword(s):  
Anaerobic Digestion ◽  
Large Scale ◽  
Treatment Process ◽  
Aqueous Ammonia ◽  
Swine Manure ◽  
Batch Experiments ◽  
Ammonia Treatment ◽  
Aqueous Ammonia Soaking ◽  
High Ammonia ◽  
Reduction Efficiency

Swine manure mono-digestion results in relatively low methane productivity due to the low degradation rate of its solid fraction (manure fibers), and due to the high ammonia and water content. The aqueous ammonia soaking (AAS) pretreatment of manure fibers has been proposed for overcoming these limitations. In this study, continuous anaerobic digestion (AD) of manure mixed with optimally AAS-treated manure fibers was compared to the AD of manure mixed with untreated manure fibers. Due to lab-scale pumping restrictions, the ratio of AAS-optimally treated manure fibers to manure was only 1/3 on a total solids (TS) basis. However, the biogas productivity and methane yield were improved by 17% and 38%, respectively, also confirming the predictions from a simplified 1st order hydrolysis model based on batch experiments. Furthermore, an improved reduction efficiency of major organic components was observed for the digester processing AAS-treated manure fibers compared to the non-treated one (e.g., 42% increased reduction for cellulose fraction). A preliminary techno-economic analysis of the proposed process showed that mixing raw manure with AAS manure fibers in large-scale digesters could result in a 72% increase of revenue compared to the AD of manure mixed with untreated fibers and 135% increase compared to that of solely manure.

pH regulation of the first phase could enhance the energy recovery from two‐phase anaerobic digestion of food waste

2021 ◽  
Author(s):  
Qing Zhao ◽  
Samuel Gyebi Arhin ◽  
Ziyi Yang ◽  
Haopeng Liu ◽  
Zongye Li ◽  
...  
Keyword(s):  
Anaerobic Digestion ◽  
Food Waste ◽  
Energy Recovery ◽  
Ph Regulation ◽  
Two Phase

Characterization, Digestibility and Anaerobic Treatment of Leachates from Old and Young Landfills

1989 ◽  
Vol 21 (4-5) ◽  
pp. 145-155 ◽  
Author(s):  
R. Méndez ◽  
J. M. Lema ◽  
R. Blázquez ◽  
M. Pan ◽  
C. Forjan
Keyword(s):  
Anaerobic Digestion ◽  
Anaerobic Treatment ◽  
Full Scale ◽  
Operating Conditions ◽  
Organic Load ◽  
Anaerobic Filter ◽  
Standards Of Living ◽  
Landfill Sites

We have evaluated the utility of applying anaerobic digestion treatment to the leachates from two landfill sites receiving solid urban refuse from populations of similar standards of living. Both tips are located in the same area and have very similar climates, but they differ as regards the length of time they have been operated. The leachates from the older tip have much lower levels of organic load, 40% of which was refractory to the anaerobic digestion treatment applied. The digestibility of leachates was studied by using a semicontinuous suspended sludge system.It was possible to remove up to 65% of the soluble COD of leachates from the young tip by means of an anaerobic filter working at HRTs less than 2 days. This system proved to be highly stable when its operating conditions were subjected to perturbations similar to those likely to be suffered by a full-scale plant.

Using Two-Phase Anaerobic Digestion for Organic Waste

2014 ◽  
Vol 953-954 ◽  
pp. 300-303 ◽  
Author(s):  
Fang Yin ◽  
Wu Di Zhang ◽  
Jing Liu ◽  
Hong Yang
Keyword(s):  
Anaerobic Digestion ◽  
Biological Treatment ◽  
Organic Waste ◽  
Single Phase ◽  
Treatment Process ◽  
Maximal Activity ◽  
Two Phase ◽  
High Efficient ◽  
Development Direction ◽  
Biological Treatment Process

The essence of the two phase anaerobic biological treatment process is to place acid bacteria and methane-producing bacteria in two reactors respectively, where it can provide the optimal conditions for their growth and metabolism, allowing them to live up to their maximal activity, which greatly improve processing capacity and efficiency compared to a single-phase anaerobic digestion. The paper start with the two phase anaerobic digestion process, in order to discuss the development direction of high efficient anaerobic digestion system.

scholarly journals CONSIDERATIONS ON RECYCLING POSSIBILITIES OF AGRO-INDUSTRIAL WASTES BY ANAEROBIC DIGESTION TREATMENT

1970 ◽  
Vol 63 ◽  
Author(s):  
Maria V. Morar
Keyword(s):  
Anaerobic Digestion ◽  
Biogas Production ◽  
Bacterial Flora ◽  
Waste Water Treatment ◽  
Treatment Plant ◽  
Water Treatment Plant ◽  
Anaerobic Treatment ◽  
Industrial Wastes ◽  
Waste Water Treatment Plant ◽  
Industrial Processing

In our country, the developments of the measures for the prevention of the environmental pollution are aligning to the UE Directives. The costs for the treatment of the water wastes are continuously increasing, following to the also increasing of the investments costs. Therefore it is necessary to accord attention for the alternatives of cleaning, treating, respective recycling of the agro-industrial wastes and their reintroduction in the natural circuit. At the processing of the food results wastes with high organic charge. The effluents form the processing of dairy products, sugar, starch, beer yeasts as well as breweries or distilleries are getting fast into acids fermentation, finally resulting organic acids. Such process water wastes can be released in the canalization by dilution or by a suitable treating. As an example, for the distillery wastes (distillery slops) with a high dry matter contents (4-20%), the waste water treatment plant shall be designed properly (with mechanical separation step and biological treatment) to ensure the capacity of purifying according to the high flow and increased concentration, due to the high CBOD5 concentration. The treatment of such water wastes can be realized with aerobic processes, which suppose a high energetic consumption. While in the aerobic purifying processes 50 % of the CBOD5 is involved in the forming of biomass and slurry in excess, in the anaerobic treatment processes (anaerobic or methane digestion) a high part of the substrate (until 70 %) is metabolized through the metabolic transformation of bacterial flora, with production of biogas. Therefore, the concentrated water wastes, with potential for the energy production could offer a possibility of energy replacement in the own processing units. The paper presents a review of the anaerobic digestion for different wastes from the agro-industrial processing and their potential for the biogas production. There are presented possibilities of mixture, respectively of co-digestion of different wastes the agro-industrial processing with other wastes from the agriculture (from cereals processing, biomass, manure etc). Simultaneously biogas plants from the praxis with functioning characteristics are presented.

scholarly journals MODELING OF COMPATIBLE WORK OF DISTRIBUTED POWER SOURCES OF ELECTRIC POWER AND CENTRALISED POWER SUPPLY

2018 ◽  
pp. 189-195
Author(s):  
Petro Lezhnyuk ◽  
Iryna Hunko ◽  
Juliya Malogulko ◽  
Iryna Kotylko ◽  
Lіudmyla Krot
Keyword(s):  
Power Supply ◽  
Power Plants ◽  
Solar Power ◽  
Energy Sources ◽  
Hydroelectric Power Station ◽  
Hydroelectric Power ◽  
Distributed Energy ◽  
Power Stations ◽  
Asynchronous Generator ◽  
Solar Power Plants

Urgency of the research. Current trends of distributed generation development in Ukraine indicate a rapid generation in-crease from renewable energy plants. Most developed countries gradually refuse from the fossil fuels use and invest more and more to the “green” energy. Therefore, there is a need for a detailed study of the operation conditions of distributed energy sources due to their instability, as well as the processes that arise in distribution electric networks with diverse types of distributed energy sources. Target setting. In the producing process of power energy by distributed energy sources due to the increase in their num-ber, there are situations where several renewable sources of energy operate to only one system of buses. Thus, such distributive networks acquire the features of a local power system, which complicates the control process of such systems, and also there is a problem with the electricity supply of consumers. Actual scientific researches and issues analysis. The analysis of publications suggests that in literature more attention is paid to studying the operating modes of solar power plants, or small hydroelectric power plants. However, almost no attention was paid to the study of their cooperation work. Uninvestigated parts of general matters defining. Only a few works are devoted to the study of the cooperation of the diverce sources of distributed energy sources in the local electrical systems. That is why, their impact on power distribution networks and on the grid in general has not been studied extensively. The research objective. In this article was considered the influence of asynchronous generators on small hydroelectric power plants on the operation modes of distribution electrical networks, and were investigated the processes that are occurring in local power systems with different types of distributed energy sources. The statement of basic materials. Based on the research results, was developed a computer model of a such system in the PS CAD software environment. Two solar stations and one small hydroelectric power station with an asynchronous generator were connected to the power supply. It was shown the simulation of two modes of operation: a joint operation of a small hydroelectric power station, two solar power stations and a power supply center; a joint operation of a small hydroelectric pow-er plant, two solar power stations and a power supply disconnected. Conclusions. As a result of computer simulation, it is shown that by switching on a small hydroelectric power plant with an asynchronous generator in the case of an emergency shutdown of centralized power supply, it is possible to restore the work of solar power plants, and thus partially or completely restore the power supply of consumers.

Sign in / Sign up

Export Citation Format

Share Document