Two-stage thermophilic-mesophilic anaerobic digestion of waste activated sludge from a biological nutrient removal plant

2006 ◽  
Vol 53 (8) ◽  
pp. 149-157 ◽  
Author(s):  
S. Watts ◽  
G. Hamilton ◽  
J. Keller
Keyword(s):  
Anaerobic Digestion ◽  
Activated Sludge ◽  
Nutrient Removal ◽  
Treatment Plant ◽  
Single Stage ◽  
Biological Nutrient Removal ◽  
Waste Activated Sludge ◽  
Two Stage ◽  
Primary Sludge ◽  
Second Stage

A two-stage thermophilic-mesophilic anaerobic digestion pilot-plant was operated solely on waste activated sludge (WAS) from a biological nutrient removal (BNR) plant. The first-stage thermophilic reactor (HRT 2 days) was operated at 47, 54 and 60 °C. The second-stage mesophilic digester (HRT 15 days) was held at a constant temperature of 36–37 °C. For comparison with a single-stage mesophilic process, the mesophilic digester was also operated separately with an HRT of 17 days and temperature of 36–37 °C. The results showed a truly thermophilic stage (60 °C) was essential to achieve good WAS degradation. The lower thermophilic temperatures examined did not offer advantages over single-stage mesophilic treatment in terms of COD and VS removal. At a thermophilic temperature of 60 °C, the plant achieved 35% VS reduction, representing a 46% increase compared to the single-stage mesophilic digester. This is a significant level of degradation which could make such a process viable in situations where there is no primary sludge generated. The fate of the biologically stored phosphorus in this BNR sludge was also investigated. Over 80% of the incoming phosphorus remained bound up with the solids and was not released into solution during the WAS digestion. Therefore only a small fraction of phosphorus would be recycled to the main treatment plant with the dewatering stream.

Oxidative and thermo-oxidative co-treatment with anaerobic digestion of excess municipal sludge

2005 ◽  
Vol 52 (1-2) ◽  
pp. 237-244 ◽  
Author(s):  
J.A. Cacho Rivero ◽  
N. Madhavan ◽  
M.T. Suidan ◽  
P. Ginestet ◽  
J.-M. Audic
Keyword(s):  
Anaerobic Digestion ◽  
Activated Sludge ◽  
Fecal Coliform ◽  
Single Stage ◽  
Waste Activated Sludge ◽  
Municipal Sludge ◽  
Two Stage ◽  
Two Stages ◽  
Solids Removal

The effect of oxidative and thermo-oxidative co-treatment of excess municipal sludge was investigated. A mixture of primary and waste activated sludge was anaerobically treated using two different configurations: i) two stages and ii) a single stage with recycling. Oxidative or thermo-oxidative co-treatment placed in between the reactor or in the recycle line was studied. A two-stage configuration with no co-treatment served as a control and resulted in 50.1% overall solids removal. Compared to the control, an increase in solids removal of 10.8 and 2.7% was observed when oxidative co-treatment was placed between reactors and in the recycle line respectively. When thermo-oxidative co-treatment was placed between the two stages or in the recycle line an increase in solids removal of 25.1 and 26.9% respectively was observed. The performances of the different configurations were also evaluated with parameters such as COD, TKN, ammonia, and fecal coliform concentration.

The main wastewater treatment plant of Vienna: an example of cost effective wastewater treatment for large cities

2006 ◽  
Vol 54 (10) ◽  
pp. 79-86 ◽  
Author(s):  
G. Wandl ◽  
H. Kroiss ◽  
K. Svardal
Keyword(s):  
Wastewater Treatment ◽  
Activated Sludge ◽  
Nitrogen Removal ◽  
Nutrient Removal ◽  
Process Management ◽  
Wastewater Treatment Plants ◽  
Treatment Plant ◽  
Single Stage ◽  
Volume Index ◽  
Two Stage

Two-stage activated sludge plants succeed in stable treatment efficiency concerning carbon removal and nitrification with far less reactor tank volume than conventional single stage systems. In case of large treatment plants this fact is of great economic relevance. Because of the very small specific volume of these two-stage treatment plants in comparison with low loaded single-stage plants, internal cycles have to be applied to ensure sufficient nitrogen removal. Due to these internal cycles two stage activated sludge plants offer many possibilities in terms of process management which results in new process optimisation procedures as compared to conventional single-stage nutrient removal treatment plants. The proposed extension concept for the Main Treatment Plant of Vienna was validated with pilot plant investigations especially with regard to nitrogen removal where it proved to comply with the legal requirements. The operation of the treatment plant can easily be adapted to changes in temperature and sludge volume index occurring in full scale practice. Sludge retention time and aerobic volume in the second stage are controlled in order to secure sufficient nitrification capacity and to optimise nitrogen removal by means of the variation of the loading conditions for the two stages. The investigations confirmed that the specific two-stage activated sludge concept applied in Vienna is an economically advantageous alternative for large wastewater treatment plants with stringent requirements for nitrification and nutrient removal.

Upgrading of the anaerobic digestion of waste activated sludge by combining temperature-phased anaerobic digestion and intermediate ozonation

2009 ◽  
Vol 59 (1) ◽  
pp. 185-193 ◽  
Author(s):  
T. Kobayashi ◽  
Y. Y. Li ◽  
H. Harada ◽  
H. Yasui ◽  
T. Noike
Keyword(s):  
Anaerobic Digestion ◽  
Activated Sludge ◽  
Treatment Plant ◽  
Waste Activated Sludge ◽  
Two Stage ◽  
Flocculation Efficiency ◽  
In Series ◽  
Stage System ◽  
Mesophilic Digestion ◽  
Pre Treatment

Upgrading of the anaerobic digestion of waste activated sludge (WAS) by the combination of temperature-phased two-stage digestion and intermediate ozonation was investigated by a continuous experiment with two processes, TM and TOM. The TM process is a temperature-phased two-stage system, which consists of a thermophilic digester and a mesophilic digester in series. The TOM process is a temperature-phased two-stage process with the intermediate ozonation. Two processes were operated at hydraulic retention times of 30 days for over 123 days. Waste activated sludge taken from wastewater treatment plant was fed as a substrate. Microbial community structure in each digester was analysed with molecular tools. Despite of less amount of ozone dose in TOM than ozone pre-treatment process, better effect of ozonation on performance improvement was obtained in TOM. TOM had the highest methane yield and CODCr reduction among comparative processes. Furthermore, flocculation efficiency of TOM followed that of mesophilic digestion. Quality of dewatered supernatant is comparable to mesophilic digestion.

Mesophilic and Thermophilic Digestion of Thickened Waste Activated Sludge: A Comparative Study

2010 ◽  
Vol 113-116 ◽  
pp. 450-458 ◽  
Author(s):  
Yong Zhi Chi ◽  
Yu You Li ◽  
Min Ji ◽  
Hong Qiang ◽  
Heng Wei Deng ◽  
...  
Keyword(s):  
Anaerobic Digestion ◽  
Activated Sludge ◽  
Municipal Wastewater ◽  
Treatment Plant ◽  
Methane Content ◽  
Waste Activated Sludge ◽  
Digested Sludge ◽  
Anaerobic Digestion Process ◽  
Digestion Process ◽  
Significant Difference

This paper presents an experimental study over 204 days on anaerobic degradation of thickened waste activated sludge (TWAS) from a municipal wastewater treatment plant (WWTP). The experiments were conducted under thermophilic (55°C) and mesophilic (35°C) condition, respectively, by using the semi-continuous flow completely mixed reactors. The influent total solids (TS), hydraulic retention time (HRT) and chemical oxygen demand (COD) loading levels were around 4%, 30 days and 1.67 kg-CODCr•m-3•d-1 , respectively. During the opration period, the thermophilic anaerobic digestion process (TADP) and the mesophilic anaerobic digestion process (MADP) were stable and well-functioned without ammonia inhibition. Particulate organic matters reduction of TADP was superior to that of MADP. This result implies that TADP has higher sludge reduction efficiency than MADP. According to the simulated chemical formula of TWAS, C5.85H9.75O3.96N, and the stoichiometric equation, the methane content and the ammonia yield in the anaerobic process could be calculated, which were consistent with the experimental results. The methane yield of TADP was a little higher than that of MADP. The statistical mean values of methane content for TADP and MADP were 60.97% and 62.38%, respectively.According to paired t-test, there was a significant difference in methane content between TADP and MADP(α=0.01, n=62). Compared with the mesophilic digested sludge, the dewaterability of thermophilic digested sludge was lower.

scholarly journals Microalgae as biological treatment for municipal wastewater – effects on the sludge handling in a treatment plant

2018 ◽  
Vol 78 (3) ◽  
pp. 644-654 ◽  
Author(s):  
J. Olsson ◽  
S. Schwede ◽  
E. Nehrenheim ◽  
E. Thorin
Keyword(s):  
Heavy Metals ◽  
Activated Sludge ◽  
Biological Treatment ◽  
Municipal Wastewater ◽  
Treatment Plant ◽  
Waste Activated Sludge ◽  
Activated Sludge Process ◽  
Primary Sludge ◽  
Thermophilic Conditions ◽  
Mesophilic Conditions

Abstract A mix of microalgae and bacteria was cultivated on pre-sedimented municipal wastewater in a continuous operated microalgae-activated sludge process. The excess material from the process was co-digested with primary sludge in mesophilic and thermophilic conditions in semi-continuous mode (5 L digesters). Two reference digesters (5 L digesters) fed with waste-activated sludge (WAS) and primary sludge were operated in parallel. The methane yield was slightly reduced (≈10%) when the microalgal-bacterial substrate was used in place of the WAS in thermophilic conditions, but remained approximately similar in mesophilic conditions. The uptake of heavy metals was higher with the microalgal-bacterial substrate in comparison to the WAS, which resulted in higher levels of heavy metals in the digestates. The addition of microalgal-bacterial substrate enhanced the dewaterability in thermophilic conditions. Finally, excess heat can be recovered in both mesophilic and thermophilic conditions.

Thermochemical pretreatment in the anaerobic digestion of waste activated sludge

2002 ◽  
Vol 46 (10) ◽  
pp. 173-179 ◽  
Author(s):  
S. Tanaka ◽  
K. Kamiyama
Keyword(s):  
Anaerobic Digestion ◽  
Activated Sludge ◽  
Sewage Treatment ◽  
Sewage Treatment Plant ◽  
Treatment Plant ◽  
Municipal Sewage ◽  
Waste Activated Sludge ◽  
Anaerobic Digesters ◽  
Thermochemical Pretreatment ◽  
Methane Production Rate

Effects of a thermochemical pretreatment on the anaerobic digestion of waste activated sludge (WAS) was investigated by semicontinuously-fed digesters operated at 37¡C. WAS from a return sludge line of a municipal sewage treatment plant was pretreated by autoclaving at 130°C for 5 minutes after adding 0.3g NaOH/g VSS. Solids of WAS were thermochemically solubilized to one half and then 60% or more were in totality solubilized in anaerobic digesters fed with pretreated WAS at 2-8 days of hydraulic retention times (HRT), while only 16-36% were solubilized in digesters fed with raw WAS. The adverse effect of the set temperature (130°C) on the biodegradability of protein was not found. As a result, removal rates of COD in digestion was increased from 38% to 57% at 8 days HRT by the pretreatment. A specific methane production rate in the pretreated process was three times as high as the normal process. The thermochemical pretreatment was found to be very effective to enhance biodegradability as well as solubilization of WAS in anaerobic digestion.

Sign in / Sign up

Export Citation Format

Share Document