scholarly journals The treatment of solvent recovery raffinate by aerobic granular sludge in a pilot-scale sequencing batch reactor

2015 ◽  
Vol 13 (3) ◽  
pp. 746-757 ◽  
Author(s):  
Bei Long ◽  
Chang-zhu Yang ◽  
Wen-hong Pu ◽  
Jia-kuan Yang ◽  
Guo-sheng Jiang ◽  
...  
Keyword(s):  
Suspended Solids ◽  
Sequencing Batch Reactor ◽  
Batch Reactor ◽  
Granular Sludge ◽  
Pilot Scale ◽  
Volume Index ◽  
Aerobic Granular Sludge ◽  
Average Particle ◽  
Solvent Recovery ◽  
Mixed Liquor

Mature aerobic granular sludge (AGS) was inoculated for the start-up of a pilot-scale sequencing batch reactor for the treatment of high concentration solvent recovery raffinate (SRR). The proportion of simulated wastewater (SW) (w/w) in the influent gradually decreased to zero during the operation, while volume of SRR gradually increased from zero to 10.84 L. AGS was successfully domesticated after 48 days, which maintained its structure during the operation. The domesticated AGS was orange, irregular, smooth and compact. Sludge volume index (SVI), SV30/SV5, mixed liquor volatile suspended solids/mixed liquor suspended solids (MLVSS/MLSS), extracellular polymeric substances, proteins/polysaccharides, average particle size, granulation rate, specific oxygen utilization rates (SOUR)H and (SOUR)N of AGS were about 38 mL/g, 0.97, 0.52, 39.73 mg/g MLVSS, 1.17, 1.51 mm, 96.66%, 47.40 mg O2/h g volatile suspended solids (VSS) and 8.96 mg O2/h g VSS, respectively. Good removal effect was achieved by the reactor. Finally, the removal rates of chemical oxygen demand (COD), total inorganic nitrogen (TIN), NH4+-N and total phosphorus (TP) were more than 98%, 96%, 97% and 97%, respectively. The result indicated gradually increasing the proportion of real wastewater in influent was a useful domestication method, and the feasibility of AGS for treatment of high C/N ratio industrial wastewater.

Cultivation of Aerobic Granular Sludge under Selective Pressure in a Sequencing Batch Reactor

2011 ◽  
Vol 255-260 ◽  
pp. 3037-3041 ◽  
Author(s):  
Kui Zu Su ◽  
Chang Wang ◽  
Hui Fang
Keyword(s):  
Suspended Solids ◽  
Sequencing Batch Reactor ◽  
Settling Velocity ◽  
Selective Pressure ◽  
Batch Reactor ◽  
Oxygen Demand ◽  
Granular Sludge ◽  
Volume Index ◽  
Aerobic Granular Sludge ◽  
Granulation Process

Aerobic granules were cultivated in the sequencing batch reactor at 15-25°C, pH 7.0 ± 0.1. Settling time decreased from 5 minutes to 1 minute gradually. As increasing the chemical oxygen demand (COD) and NH3-N in influent, COD removal efficiency and mixed liquid suspended solids of the reactor increased. Sludge volume index decreased continuously for a few days and then stabilized at 22 ml g-1. Selective pressure induced by settling velocity was proved to play a crucial role in activated sludge granulation. Based on the continuously measured data, the granulation process was divided into three phases, granules namely initiating, developing and maturating.

scholarly journals Co-treatment of old landfill leachate and municipal wastewater in sequencing batch reactor (SBR): effect of landfill leachate concentration

2016 ◽  
Vol 51 (4) ◽  
pp. 377-387 ◽  
Author(s):  
Kshitij Ranjan ◽  
Shubhrasekhar Chakraborty ◽  
Mohini Verma ◽  
Jawed Iqbal ◽  
R. Naresh Kumar
Keyword(s):  
Removal Efficiency ◽  
Landfill Leachate ◽  
Suspended Solids ◽  
Sequencing Batch Reactor ◽  
Municipal Wastewater ◽  
Batch Reactor ◽  
Operating Conditions ◽  
Volume Index ◽  
Turbidity Removal ◽  
Mixed Liquor

Sequencing batch reactor (SBR) was assessed for direct co-treatment of old landfill leachate and municipal wastewater for chemical oxygen demand (COD), nutrients and turbidity removal. Nitrogen removal was achieved by sequential nitrification and denitrification under post-anoxic conditions. Initially, SBR operating conditions were optimized by varying hydraulic retention time (HRT) at 20% (v/v) landfill leachate concentration, and results showed that 6 d HRT was suitable for co-treatment. SBR performance was assessed in terms of COD, ammonia, nitrate, phosphate, and turbidity removal efficiency. pH, mixed liquor suspended solids, mixed liquor volatile suspended solids (MLVSS), and sludge volume index were monitored to evaluate stability of SBR. MLVSS indicated that biomass was able to grow even at higher concentrations of old landfill leachate. Ammonia and nitrate removal efficiency was more than 93% and 83%, respectively, whereas COD reduction was in the range of 60–70%. Phosphate and turbidity removal efficiency was 80% and 83%, respectively. Microbial growth kinetic parameters indicated that there was no inhibition of biomass growth up to 20% landfill leachate. The results highlighted that SBR can be used as an initial step for direct co-treatment of landfill leachate and municipal wastewater.

scholarly journals A Bioreactor Designed for Restricting Oversize of Aerobic Granular Sludge

Processes ◽  
2021 ◽  
Vol 9 (2) ◽  
pp. 374
Author(s):  
Hongbo Feng ◽  
Honggang Yang ◽  
Jianlong Sheng ◽  
Zengrui Pan ◽  
Jun Li
Keyword(s):  
Particle Size ◽  
Batch Reactor ◽  
Oxygen Demand ◽  
Granular Sludge ◽  
Pilot Scale ◽  
Ammonia Nitrogen ◽  
Pollutant Removal ◽  
Volume Index ◽  
Aerobic Granular Sludge ◽  
Air Bubbles

Aerobic granular sludge (AGS) with oversized diameter commonly affects its stability and pollutant removal. In order to effectively restrict the particle size of AGS, a sequencing batch reactor (SBR) with a spiny aeration device was put forward. A conventional SBR (R1) and an SBR (R2) with the spiny aeration device treating tannery wastewater were compared in the laboratory. The result indicates that the size of the granular sludge from R2 was smaller than that from R1 with sludge granulation. The spines and air bubbles could effectively restrict the particle size of AGS by collision and abrasion. Nevertheless, there was no significant change in mixed liquor suspended solids (MLSS) and the sludge volume index (SVI) in either bioreactors. The removal (%) of chemical oxygen demand (COD) and ammonia nitrogen (NH4+-N) in these two bioreactors did not differ from each other greatly. The analysis of biological composition displays that the proportion of Proteobacteria decreased slightly in R2. The X-ray fluorescence (XRF) analysis revealed less accumulation of Fe and Ca in smaller granules. Furthermore, a pilot-scale SBR with a spiny aeration device was successfully utilized to restrict the diameter of granules at about 300 μm.

Cultivation of polyhydroxybutyrate-rich aerobic granular sludge in a sequencing batch reactor

2006 ◽  
Vol 6 (6) ◽  
pp. 81-87 ◽  
Author(s):  
J. Wang ◽  
H.Q. Yu
Keyword(s):  
Sequencing Batch Reactor ◽  
Batch Reactor ◽  
Granular Sludge ◽  
Volume Index ◽  
Synthetic Wastewater ◽  
Aerobic Granular Sludge ◽  
Second Step ◽  
Sludge Volume Index ◽  
Flat Shape ◽  
Sludge Granulation

In this study a two-step strategy was adopted to cultivate Polyhydroxybutyrate (PHB)-rich aerobic granular sludge in a sequencing batch reactor (SBR) fed with a synthetic wastewater. In the first step both oxygen and ammonia were initially limited, in order to enhance the PHB-storage ability of sludge. In the second step granular sludge was cultivated to get a high PHB volumetric productivity. The PHB content of sludge increased to 43.1±2.0% in the first step. During the sludge granulation, the PHB content was constant at 40±4.6%. With the granulation, the settling ability of the PHB-rich sludge continuously improved, as evidenced by a decreased sludge volume index. The matured PHB-rich granular sludge presented a buff color and regular morphology with elliptical and flat shape.

Aerobic granular sludge: a promising technology for decentralised wastewater treatment

2006 ◽  
Vol 53 (9) ◽  
pp. 79-85 ◽  
Author(s):  
Z.H. Li ◽  
T. Kuba ◽  
T. Kusuda
Keyword(s):  
Sequencing Batch Reactor ◽  
Loading Rate ◽  
Batch Reactor ◽  
Granular Sludge ◽  
Volume Index ◽  
Synthetic Wastewater ◽  
Aerobic Granular Sludge ◽  
Organic Loading Rate ◽  
Organic Loading ◽  
Fast Settling

In order to evaluate the characteristics of aerobic granular sludge, a sequencing batch reactor, feeding with synthetic wastewater at the organic loading rate of 8 kg COD/m3 d, was employed on the laboratory scale. Granules occurred in the reactor within 1 week after the inoculation from conventional flocculent sludge. Aerobic granular sludge was characterised by the outstanding settling properties and considerable contaminates removal efficiencies. The SVI30 values were in the range of 20 to 40 ml g−1. However, the sludge volume index of short settling time (e.g. SVI10 – 10 min) is suggested to describe the fast settling properties of aerobic granular sludge. The potential application in the decentralised system is evaluated from the point view of footprint and high bioactivity. The occurrence of sloughing, resulting from the outgrowth of filamentous organisms, would be responsible for the instability of aerobic granules. The starvation phase should therefore be carefully controlled for the maintenance and stability of aerobic granular sludge system.

Effect of COD/N ratio on cultivation of aerobic granular sludge in a pilot-scale sequencing batch reactor

2012 ◽  
Vol 97 (4) ◽  
pp. 1745-1753 ◽  
Author(s):  
Dong Wei ◽  
Zhuangming Qiao ◽  
Yongfang Zhang ◽  
Lianjie Hao ◽  
Wei Si ◽  
...  
Keyword(s):  
Sequencing Batch Reactor ◽  
Batch Reactor ◽  
Granular Sludge ◽  
Pilot Scale ◽  
Aerobic Granular Sludge

Rapid cultivation of aerobic granular sludge in a pilot scale sequencing batch reactor

2014 ◽  
Vol 166 ◽  
pp. 57-63 ◽  
Author(s):  
Bei Long ◽  
Chang-zhu Yang ◽  
Wen-hong Pu ◽  
Jia-kuan Yang ◽  
Guo-sheng Jiang ◽  
...  
Keyword(s):  
Sequencing Batch Reactor ◽  
Batch Reactor ◽  
Granular Sludge ◽  
Pilot Scale ◽  
Aerobic Granular Sludge
Sign in / Sign up

Export Citation Format

Share Document