Extending Run Times of Produced Water Coolers in Steam Assisted Gravity Drainage Production Using Anti-Foulant Applications

2020 ◽  
Author(s):  
Sean Stewart ◽  
John Lerbscher ◽  
Dave Mamprin ◽  
Brian Stefan
Keyword(s):  
Produced Water ◽  
Gravity Drainage ◽  
Steam Assisted Gravity Drainage

Phase Analysis of Scale Deposition in Boiler Tubes Utilizing Steam-Assisted Gravity Drainage Produced Water

2016 ◽  
Vol 9 (1) ◽  
Author(s):  
Raymond Kuriger ◽  
David Young ◽  
Malcolm Mackenzie ◽  
Hamid Sarv ◽  
Jason Trembly
Keyword(s):  
Heat Transfer ◽  
Produced Water ◽  
Magnesium Silicate ◽  
Solid Content ◽  
Operating Conditions ◽  
Gravity Drainage ◽  
Dissolved Solids ◽  
X Ray ◽  
Steam Assisted Gravity Drainage ◽  
Boiler Tubes

Scale buildup on water-side heat transfer surfaces poses a potential operating challenge for steam-assisted gravity drainage (SAGD) boilers used in the production of bitumen since produced water, which has a high dissolved solid content, is recycled. Scale from deposition of dissolved solids on boiler tubes acts as a thermal insulating layer, decreasing heat transfer and lowering boiler efficiency. Understanding scale deposit composition on heat transfer surfaces is beneficial in the determination of adequate boiler maintenance practices and operating parameters. This research determined the effect of feedwater pH (7.5, 9.0, and 10.0) on scale composition resulting from deposition of dissolved solids under commercially relevant boiler operating conditions at 8.96 MPa (1300 psig) and 37.86 kW/m2 (12,000 Btu/h ft2). Scale deposits were analytically investigated using scanning electron microscopy coupled with energy dispersive X-ray spectroscopy (SEM/EDS), powder X-ray diffraction (XRD), and Raman spectroscopy. At feedwater pH values of 7.5 and 9.0, anhydrite (CaSO4), xonotlite (Ca6Si6O17(OH)2), and pectolite (NaCa2Si3O8(OH)) were detected. At the pH of 10.0, xonotlite and pectolite were identified in the absence of anhydrite. Furthermore, the magnesium silicate phase, serpentine (Mg3Si2O5(OH)4), was also postulated to be present.

Effect of Steam-Assisted Gravity Drainage Produced Water Properties on Oil/Water Transient Interfacial Tension

2016 ◽  
Vol 30 (12) ◽  
pp. 10714-10720 ◽  
Author(s):  
Maryam Razi ◽  
Shayandev Sinha ◽  
Prashant R. Waghmare ◽  
Siddhartha Das ◽  
Thomas Thundat
Keyword(s):  
Interfacial Tension ◽  
Produced Water ◽  
Gravity Drainage ◽  
Water Properties ◽  
Steam Assisted Gravity Drainage ◽  
Oil Water

scholarly journals Identifying Reservoir Features via iSOR Response Behaviour

Energies ◽  
2021 ◽  
Vol 14 (2) ◽  
pp. 427
Author(s):  
Jingyi Wang ◽  
Ian Gates
Keyword(s):  
Oil Sands ◽  
Gravity Drainage ◽  
Athabasca Oil Sands ◽  
Steam Chamber ◽  
Heterogeneous Reservoirs ◽  
Steam Assisted Gravity Drainage ◽  
Response Behaviour

To extract viscous bitumen from oil sands reservoirs, steam is injected into the formation to lower the bitumen’s viscosity enabling sufficient mobility for its production to the surface. Steam-assisted gravity drainage (SAGD) is the preferred process for Athabasca oil sands reservoirs but its performance suffers in heterogeneous reservoirs leading to an elevated steam-to-oil ratio (SOR) above that which would be observed in a clean oil sands reservoir. This implies that the SOR could be used as a signature to understand the nature of heterogeneities or other features in reservoirs. In the research reported here, the use of the SOR as a signal to provide information on the heterogeneity of the reservoir is explored. The analysis conducted on prototypical reservoirs reveals that the instantaneous SOR (iSOR) can be used to identify reservoir features. The results show that the iSOR profile exhibits specific signatures that can be used to identify when the steam chamber reaches the top of the formation, a lean zone, a top gas zone, and shale layers.

Dissolved Organic Matter in Steam Assisted Gravity Drainage Boiler Blow-Down Water

2013 ◽  
Vol 27 (7) ◽  
pp. 3883-3890 ◽  
Author(s):  
Subhayan Guha Thakurta ◽  
Abhijit Maiti ◽  
David J. Pernitsky ◽  
Subir Bhattacharjee
Keyword(s):  
Organic Matter ◽  
Dissolved Organic Matter ◽  
Gravity Drainage ◽  
Blow Down ◽  
Steam Assisted Gravity Drainage
Sign in / Sign up

Export Citation Format

Share Document