Grain Growth in Vapor Deposited Aluminium Alloys

1986 ◽  
Vol 77 ◽  
Author(s):  
Uwe Köster ◽  
Paul S. Ho

ABSTRACTIn a number of vapor deposited aluminium alloys grain growth has been investigated systematically by means of quantitative electron microscopy and found to proceed not by grain boundary migration, but by grain coalescence. Parameters influencing the observed mode of grain growth will be discussed with respect to the formation of microstructures with optimal resistance to electromigration, i.e. microstructures with large grain size, high homogeneity in the grain size distribution as well as a strong texture.Analyses of grain size distribution after annealing indicate a strong retardation in grain growth by the solute in all aluminium alloys except Al(Cu). Relative large grain sizes and very small lognormal standard deviations have been observed in Al-l%Cu as well as ternary Al(Cu,Hf) thin films.

2007 ◽  
Vol 558-559 ◽  
pp. 1183-1188 ◽  
Author(s):  
Peter Streitenberger ◽  
Dana Zöllner

Based on topological considerations and results of Monte Carlo Potts model simulations of three-dimensional normal grain growth it is shown that, contrary to Hillert’s assumption, the average self-similar volume change rate is a non-linear function of the relative grain size, which in the range of observed grain sizes can be approximated by a quadratic polynomial. In particular, based on an adequate modification of the effective growth law, a new analytical grain size distribution function is derived, which yields an excellent representation of the simulated grain size distribution.


1992 ◽  
Vol 94-96 ◽  
pp. 325-330 ◽  
Author(s):  
Y. Takayama ◽  
T. Tozawa ◽  
H. Kato ◽  
Norio Furushiro ◽  
S. Hori

2011 ◽  
Vol 409 ◽  
pp. 597-602
Author(s):  
Yuichi Mizuno ◽  
Kenji Okushiro ◽  
Yoshiyuki Saito

Grain boundary migration in materials under severe plastic deformation was simulated by the phase field methods. The interface energy and dislocation density on growth kinetics were simulated on systems of 2-dimensional lattice. .In inhomogeneous systems grain size distributions in simulated grain structures were binodal distributions. The classification of the solution of differential equations based on the mean-field Hillert model describing temporal evolution of the scaled grain size distribution function was in good agreement with those given by the Computer simulations. Effect of dislocation on thermodynamic stability was taken into consideration. Dislocation density distribution was calculated by a equation based on the diffusion-reaction equation.. Scaled grain size distribution was known to be affected by the dislocation.


1996 ◽  
Vol 34 (8) ◽  
pp. 1225-1230 ◽  
Author(s):  
S. Vogel ◽  
P. Klimanek ◽  
D.Juul Jensen ◽  
H. Richter

1988 ◽  
Vol 128 ◽  
Author(s):  
Joyce C. Liu ◽  
Jian Li ◽  
J. W. Mayer ◽  
Charles W. Allen ◽  
Lynn E. Rehn

ABSTRACTIn situ observations of 1.5 MeV Xe+ ion irradiated Au films at room temperature and at 150°C reveal the evolution of grain growth: the average grain size increases by the mechanisms of grain boundary migration and grain coalescence.


2021 ◽  
Author(s):  
Mark Coleman ◽  
Bernhard Grasemann ◽  
David Schneider ◽  
Konstantinos Soukis ◽  
Riccardo Graziani

<p>Microstructures may be used to determine the processes, conditions and kinematics under which deformation occurred. For a given set of these variables, different microstructures are observed in various materials due to the material’s physical properties. Dolomite is a major rock forming mineral, yet the mechanics of dolomite are understudied compared to other ubiquitous minerals such as quartz, feldspar, and calcite. Our new study uses petrographic, structural and electron back scatter diffraction analyses on a series of dolomitic and calcitic mylonites to document differences in deformation styles under similar metamorphic conditions. The Attic-Cycladic Crystalline Complex, Greece, comprises a series of core complexes wherein Miocene low-angle detachment systems offset and juxtapose a footwall of high-pressure metamorphosed rocks against a low-grade hanging wall. This recent tectonic history renders the region an excellent natural laboratory for studying the interplay of the processes that accommodate deformation. The bedrock of Mt. Hymittos, Attica, preserves a pair of ductile-then-brittle normal faults dividing a tripartite tectonostratigraphy. Field observations, mineral assemblages and observable microstructures suggests the tectonic packages decrease in metamorphic grade from upper greenschist facies (~470 °C at 0.8 GPa) in the stratigraphically lowest package to sub-greenschist facies in the stratigraphically highest package. Both low-angle normal faults exhibit cataclastic fault cores that grade into the schists and marbles of their respective hanging walls. The middle and lower tectonostratigraphic packages exhibit dolomitic and calcitic marbles that experienced similar geologic histories of subduction and exhumation. The mineralogically distinct units (calcite vs. dolomite) of the middle package deformed via different mechanisms under the same conditions within the same package and may be contrasted with mineralogically similar units that deformed under higher pressure and temperature conditions in the lower package. In the middle unit, dolomitic rocks are brittlely deformed. Middle unit calcitic marble are mylonitic to ultramylonitic with average grain sizes ranging from 30 to 8 μm. These mylonites evince grain-boundary migration and grain size reduction facilitated by subgrain rotation. Within the lower package, dolomitic and calcitic rocks are both mylonitic to ultramylonitic with grain sizes ranging from 28 to 5 μm and preserve clear crystallographic preferred orientation fabrics. Calcitic mylonites exhibit deformation microstructures similar to those of the middle unit. Distinctively, the dolomitic mylonites of the lower unit reveal ultramylonite bands cross-cutting and overprinting an older coarser mylonitic fabric. Correlated missorientation angles suggest these ultramylonites show evidence for grain size reduction accommodated by microfracturing and subgrain rotation. In other samples the dolomitic ultramylonite is the dominant fabric and is overprinting and causing boudinage of veins and relict coarse mylonite zones. Isolated interstitial calcite grains within dolomite ultramylonites are signatures of localized creep-cavitation processes. Following grain size reduction, grain boundary sliding dominantly accommodated further deformation in the ultramylonitic portions of the samples as indicated by randomly distributed correlated misorientation angles. This study finds that natural deformation of dolomitic rocks may occur by different mechanisms than those identified by published experiments; notably that grain-boundary migration and subgrain rotation may be active in dolomite at much lower temperatures than previously suggested.</p>


2019 ◽  
Vol 11 (1) ◽  
pp. 29-36 ◽  
Author(s):  
Rui Yuan ◽  
Bo Yang ◽  
Yingfei Liu ◽  
Lingyu Huang

Abstract Because of the laboratory operating, the fineending of grain-size distribution (GSD) are simply combined as one point, which results in the information loss of the fine and very-fine clastic particles, and affects the geological parameters calculation of GSD. To remove the fine-endings, a modified Gompertz sigmoidal model is proposed in this paper. The first stage is establishing and solving the modified Gompertz sigmoidal model; the second stage is fitting and evaluating the cumulative probability and frequency of GSD; the third stage is calculating the geological parameters. Taking 113 samples for example, coefficients of determination (COD) between measured and fitted individual cumulative probability and frequency are bigger than 0.98980 and 0.97000 respectively, which proves the goodness of fitting results. By moments method using frequency data, the COD between fitted and measured mean is 0.97578, while CODs of sorting, skewness and kurtosis are in low values, which suggest that the fine-endings has little influence on the average grain-sizes of GSD and large influence on its geometry. Besides, modified Gompertz sigmoidal model offers another quick numerical way to calculate median, mean and sorting of GSD by graphical method using cumulative probability data. The proposed method is useful to remove the fine-endings and contribute to calculate the geological parameters of GDS.


1989 ◽  
Vol 53 (2) ◽  
pp. 164-169
Author(s):  
Yoshimasa Takayama ◽  
Tatsumi Tozawa ◽  
Hajime Kato ◽  
Norio Furushiro ◽  
Shigenori Hori

Sign in / Sign up

Export Citation Format

Share Document