Simulation of Hydrogen Sulfide Emission from Deep-Pit Manure Storage During Agitation

2018 ◽  
Vol 61 (6) ◽  
pp. 1951-1967
Author(s):  
Hongjian Lin ◽  
Weiwei Liu ◽  
Jing Gan ◽  
Yuchuan Wang ◽  
Bo Hu
Keyword(s):  
Mass Transfer ◽  
Hydrogen Sulfide ◽  
Main Part ◽  
Molecular Diffusion ◽  
Mass Transfer Rate ◽  
Swine Manure ◽  
Health And Safety ◽  
Sulfide Concentration ◽  
Deep Pit ◽  
Simulation Results

Abstract. Human and animal exposure to hydrogen sulfide (H2S) in animal barns has long been a serious issue due to the acute and chronic toxicity of H2S. The H2S concentration in the room air of deep-pit swine barns is usually within hundreds of parts per billion by volume; however, it can sharply increase to hundreds and even thousands of parts per million (ppm) during manure agitation and pump-out. To explore the sudden release and concentration distribution of H2S, this study collected and analyzed samples from varying depths of a normal non-foaming barn and a foaming barn and then mathematically simulated the H2S concentrations and emissions in the pit headspace and room air for both barns during pit agitation. Simulations were conducted for six ventilation scenarios, or six different combinations of pit fan and wall fan ventilation rates. The simulation results suggested that pit ventilation was more effective than wall ventilation in decreasing H2S concentration in room air where pigs may be housed during agitation. A minimal pit ventilation rate of 40 cfm per pig was necessary to lower the peak concentration in room air to less than the permissible exposure limit of 20 ppm. The simulation results also indicated that gas bubble release during agitation accounted for the main part (81%) of H2S emission in the foaming barn, and expedited molecular diffusion contributed the main part (70.2%) of H2S emission in the non-foaming barn. The disturbed air-manure interface during agitation induced a pH decrease and therefore increased the apparent overall mass transfer coefficient of H2S, resulting in a substantially increased mass transfer rate and concentration. The immediately dangerous to life or health (IDLH) concentration of 100 ppm may be reached during pit agitation if pit fan ventilation is not fully provided, and the duration of the exceedance could be more than 30 min. The results provide empirical data for future simulation of spatial and temporal H2S distribution and are beneficial for developing methods to control H2S below hazardous levels so that the health and safety of workers can be better secured. Keywords: Agricultural safety, Deep-pit storage, Hydrogen sulfide concentration, Sulfide distribution, Swine manure.

Electrochemical mitigation of hydrogen sulfide in deep-pit swine manure storage

2021 ◽  
pp. 146048
Author(s):  
Lingkan Ding ◽  
Hongjian Lin ◽  
Brian Hetchler ◽  
Yuchuan Wang ◽  
Wei Wei ◽  
...  
Keyword(s):  
Hydrogen Sulfide ◽  
Swine Manure ◽  
Deep Pit ◽  
Manure Storage

scholarly journals Analysis of Nonlinear Dynamics for Abrupt Change of Interphase Structure in Liquid-Liquid Mass Transfer

2009 ◽  
Vol 2009 ◽  
pp. 1-13
Author(s):  
DongXiang Zhang ◽  
Min Sun ◽  
Jing Li
Keyword(s):  
Mass Transfer ◽  
Molecular Diffusion ◽  
Abrupt Change ◽  
Mass Transfer Rate ◽  
Mass Transfer Process ◽  
Liquid System ◽  
Phase Portraits ◽  
Liquid Mass ◽  
Liquid Mass Transfer ◽  
Parameter Ranges

As a liquid-liquid system is far from equilibrium state, the phase thickness is variable when mass transfer process with chemical reaction occurs in interphase zone, and a dispersible transitional layer called the interphase dispersed zone (IDZ) is formed. The IZD model composed of thermodynamically instable O/W or W/O microemulsion has reasonably explained enormous experimental phenomena in nonlinear mass transfer. To forecast the possible parameter ranges of IDZ process and abrupt change of liquid-liquid mass transfer rate, the dynamic characteristics of a molecular diffusion model are considered in this paper. We applied the bifurcation theory of planar dynamical system, Laplace transform, and maple software to investigate the model, and obtain different phase portraits of the system in different regions. The results obtained will play an important directive role in the study of IDZ model.

Free Convective Mass Transfer at Isosceles Triangular Surfaces of Varying Inclination

2003 ◽  
Vol 68 (11) ◽  
pp. 2080-2092 ◽  
Author(s):  
Martin Keppert ◽  
Josef Krýsa ◽  
Anthony A. Wragg
Keyword(s):  
Mass Transfer ◽  
Transfer Rate ◽  
Mass Transfer Rate ◽  
Mass Transfer Process ◽  
Sulfate Solution ◽  
Convective Mass Transfer ◽  
Varying Length ◽  
Inclined Surface ◽  
Vertical Case ◽  
Limiting Diffusion Current

The limiting diffusion current technique was used for investigation of free convective mass transfer at down-pointing up-facing isosceles triangular surfaces of varying length and inclination. As the mass transfer process, copper deposition from acidified copper(II) sulfate solution was used. It was found that the mass transfer rate increases with inclination from the vertical to the horizontal position and decreases with length of inclined surface. Correlation equations for 7 angles from 0 to 90° were found. The exponent in the ShL-RaL correlation ranged from 0.247 for the vertical case, indicating laminar flow, to 0.32 for inclinations of 60 to 90°, indicating mixed or turbulent flow. The general correlation ShL = 0.358(RaL sin θ)0.30 for the RaL sin θ range from 7 × 106 to 2 × 1011 and inclination range from 15 to 90° was obtained.

scholarly journals PSIX-9 Impacts of bunk management on feedlot performance, carcass characteristics, hydrogen sulfide concentration and blood oxygen saturation in steers fed 25 or 50% modified distillers grains plus solubles

2020 ◽  
Vol 98 (Supplement_4) ◽  
pp. 422-422
Author(s):  
Rebecca L Moore ◽  
Cierrah J Kassetas ◽  
Leslie A LeKatz ◽  
Bryan W Neville
Keyword(s):  
Hydrogen Sulfide ◽  
Oxygen Saturation ◽  
Management Strategy ◽  
Distillers Grains ◽  
Feed Ratio ◽  
Sulfide Concentration ◽  
Blood Oxygen ◽  
Blood Oxygen Saturation ◽  
Feedlot Performance ◽  
Arterial Blood

Abstract One hundred and twenty-six yearling angus steers (initial body weight 445.87 ± 7.13 kg) were utilized in a 2 x 2 factorial design to evaluate the impacts of bunk management and modified distillers grains plus solubles (mDGS) inclusion on feedlot performance, hydrogen sulfide concentrations and blood oxygen saturation. Treatments included bunk management strategy either control bunk management (CON; clean bunks at the time of next day’s feeding) or long bunk management (LONG; feed remaining at time of next day’s feeding), and two inclusion rates of mDGS either 25% or 50% (DM Basis). On d 0, 7, 14, 21, 28 and 35 rumen gas samples were collected via rumenocentesis, and arterial blood samples were collected on two steers from each pen. No differences (P ≥ 0.09) were observed for dry matter intake, average daily gain and gain-to-feed ratio for bunk management or mDGS inclusion. Hot carcass weight, ribeye area, marbling score and quality grade were not affected (P ≥ 0.48) by either bunk management or mDGS inclusion. Back fat was greater (P = 0.04) for CON steers compared to LONG (1.30 vs 1.12 ± 0.05cm, respectively), but was not affected (P = 0.59) by mDGS inclusion. Steers on CON had greater (P = 0.03) yield grades compared to LONG (3.21 vs 2.96 ± 0.11, respectively). Bunk management strategy did not impact hydrogen sulfide concentrations or blood oxygen saturation (P = 0.82). Hydrogen sulfide concentrations increased (P < 0.001) with increasing mDGS inclusion. Blood oxygen saturation was influenced by day of sampling (P = 0.01). Blood oxygen saturation was not affected (P = 0.07) by mDGS inclusion. The fact that ruminal hydrogen sulfide concentrations increased while blood oxygen saturation remained similar raises questions about the quantity of hydrogen sulfide and metabolic fate of excess hydrogen sulfide in the blood of ruminant animals.

Distributed mass transfer rate for modelling the leaching of porous granular materials containing soluble pollutants

2000 ◽  
Vol 55 (7) ◽  
pp. 1257-1267 ◽  
Author(s):  
Tiruta-Barna Ligia ◽  
Barna Radu ◽  
Moszkowicz Pierre ◽  
Bae Hae-Ryong
Keyword(s):  
Mass Transfer ◽  
Granular Materials ◽  
Transfer Rate ◽  
Mass Transfer Rate

Enhancement of formic acid production from CO2 in formate dehydrogenase reaction using nanoparticles

RSC Advances ◽  
2016 ◽  
Vol 6 (111) ◽  
pp. 109978-109982 ◽  
Author(s):  
Young-Kee Kim ◽  
Sung-Yeob Lee ◽  
Byung-Keun Oh
Keyword(s):  
Mass Transfer ◽  
Formic Acid ◽  
Acid Production ◽  
Transfer Rate ◽  
Formate Dehydrogenase ◽  
Mass Transfer Rate ◽  
Liquid Mass ◽  
Dehydrogenase Reaction ◽  
Liquid Mass Transfer ◽  
Mesoporous Nanoparticles

In an enzyme process using a gas substrate, the enhanced gas liquid mass transfer rate of the gas substrate by methyl-functionalized mesoporous nanoparticles could improve the productivity.

Sign in / Sign up

Export Citation Format

Share Document