Production of Transglutaminase by a Local Streptomyces Isolate Using Wheat Bran

2013 ◽  
Vol 9 (1) ◽  
pp. 33-42 ◽  
Author(s):  
Waleed Ahmed Mahmood
Keyword(s):  
Wheat Bran ◽  
Streptomyces Isolate

Cultivation and Harvesting of Selenium-Enriched Ganoderma lingzhi and Spent Medium Using Kudzu Vine as Substrate

2019 ◽  
Vol 18 (2) ◽  
pp. 152-157
Author(s):  
Zeng Xianlu ◽  
Han Fei ◽  
Zhong Yanmei
Keyword(s):  
Growth Medium ◽  
Wheat Bran ◽  
Fruiting Body ◽  
Sodium Selenite ◽  
Human Consumption ◽  
Growth Substrate ◽  
Organic Selenium ◽  
Significant Difference ◽  
Ganoderma Lingzhi ◽  
Run Speed

In order to harvest selenium-enriched fruiting body and spores of Ganoderma lingzhi and spent medium, G. lingzhi was cultivated in kudzu vine as substrate and the bio-transformation of selenite was evaluated. The growth medium consisted of Kudzu vine supplemented with 20% wheat bran or sawdust or none. The growth medium was supplemented with 0, 10, 20, 30, and 50 mg/kg of sodium selenite. We found a significant difference in spawn run speed, fruiting body and spore yields when Kudzu vine was supplemented with wheat bran or sawdust. However, when whole-kudzu vine was used alone as substrate, it resulted in a significantly lower spawn run speed, fruiting body, and spore yields compared with kudzu vine + sawdust substrate and kudzu vine + wheat bran substrate. The selenium content in fruiting body and spores increased with increasing sodium selenite supplementation and approximately equaled half of the selenium in the substrate. No selenite was detected in both the fruiting body and spores. However, in the spent medium when sodium selenite was supplemented at 10, 20, 30, 50 mg/kg, the residual selenite concentration decreased to 0.45, 0.72, 1.29, and 1.95 mg/kg, respectively, suggesting a higher selenite transformation (92.27–93.57%). In conclusion, if Ganoderma fruiting body and spores were to be harvested for human consumption, approximately 50 mg/kg selenite should be added to the growth substrate. On the other hand, if the spent medium was to be used as an organic selenium source, the optimal sodium selenite supplementation level would be 10 mg/kg.

scholarly journals Utilization of wheat germ oil and wheat bran fiber as fat replacer for the development of low‐fat beef patties

2021 ◽  
Author(s):  
Anam Khalid ◽  
Muhammad Sohaib ◽  
Muhammad Tahir Nadeem ◽  
Farhan Saeed ◽  
Ali Imran ◽  
...  
Keyword(s):  
Wheat Bran ◽  
Wheat Germ ◽  
Wheat Germ Oil ◽  
Low Fat ◽  
Fat Replacer ◽  
Beef Patties

scholarly journals The Sustainable Production of a Novel Laccase from Wheat Bran by Bordetella sp. JWO16: Toward a Total Environment

Catalysts ◽  
2021 ◽  
Vol 11 (6) ◽  
pp. 677
Author(s):  
John Onolame Unuofin
Keyword(s):  
Wheat Bran ◽  
Contaminated Soils ◽  
Residual Activity ◽  
Dye Decolorization ◽  
Fermentation Medium ◽  
Biochemical Properties ◽  
Synthetic Dyes ◽  
High Concentrations ◽  
Capital Intensive ◽  
Agroindustrial Residue

Laccase is increasingly adopted in diverse industrial and environmental applications, due to its readily accessible requirements for efficient catalytic synthesis and biotransformation of chemicals. However, it is perceived that its industrial production might incur some unfavorable overhead, which leads to expensive market products, and the corresponding negative environmental feedback, due to the use of capital-intensive and precarious chemicals. To this end, this study was designed to evaluate the performance indicators of the valorization of wheat bran by a novel Jb1b laccase and its subsequent application in waste minimization and water management, on a laboratory scale. Optimal Jb1b laccase was produced in submerged fermentation medium containing wheat bran, an agroindustrial residue, through response surface methodology (RSM) algorithm, and was applied in dye decolorization and denim bioscouring, respectively. Results showed that the resultant enzyme manifested unique biochemical properties, such as enhanced tolerance at certain physicochemical conditions, with a residual activity of at least ca. 76%. Furthermore, phenomenally high concentrations of synthetic dyes (0.2% w v−1) were decolorized over 56 h, and a 6 h mediator-supported simultaneous denim bleaching and decolorization of wash effluent was observed. The sustainability of the production and application processes were inferred from the reusability of the fermentation sludge as a potential biofertilizer, with subsequent prospects for the biostimulation and bioaugmentation of contaminated soils, whereas the decolorized water could be adopted for other uses, amongst which horticulture and forestry are typical examples. These phenomena therefore authenticate the favorable environmental feedbacks and overhead realized in this present study.

scholarly journals Taguchi optimization and scale up of xylanase from Bacillus licheniformis isolated from hot water geyser

2020 ◽  
Vol 18 (1) ◽  
Author(s):  
Girisha Malhotra ◽  
Shilpa S. Chapadgaonkar
Keyword(s):  
Process Parameters ◽  
Wheat Bran ◽  
Scale Up ◽  
Industrial Applications ◽  
Hot Water ◽  
Optimization Strategy ◽  
Taguchi Optimization ◽  
Xylanase Production ◽  
Alkali Tolerance ◽  
Optimized Conditions

Abstract Background Xylanase is one of the widely applied industrial enzymes with diverse applications. Thermostability and alkali tolerance are the two most desirable qualities for industrial applications of xylanase. In this paper, we reveal the statistical Taguchi optimization strategy for maximization of xylanase production. The important process parameters pH, temperature, concentration of wheat bran, and concentration of yeast extract were optimized using the Taguchi L8 orthogonal array where the 4 factors were considered at 2 levels (high and low). Results The optimized conditions given by model were obtained as follows: (i) pH 6, (ii) culture temperature 35 °C, (iii) concentration of xylan 2% w/v, (iv) concentration of wheat bran 2.5% w/v. The production was scaled upto 2.5 L bioreactor using optimized process parameters. A high xylanase titer of 400 U/ml could be achieved in less than 60 h of culture in the reactor. Conclusion Optimization was successful in achieving about threefold increase in the yield of xylanase. The optimized conditions resulted in a successful scale up and enhancement of xylanase production.

Effect of wheat bran and maize straw substrates on the agronomic traits and nutritional content of Auricularia cornea cv. Yu Muer

2021 ◽  
Vol 286 ◽  
pp. 110200
Author(s):  
Yanqi Chen ◽  
Frederick Leo Sossah ◽  
Zhiwen Lv ◽  
Yancong Lv ◽  
Long Tian ◽  
...  
Keyword(s):  
Wheat Bran ◽  
Agronomic Traits ◽  
Nutritional Content ◽  
Maize Straw

scholarly journals β-Galactosidase-Producing Isolates in Mucoromycota: Screening, Enzyme Production, and Applications for Functional Oligosaccharide Synthesis

2021 ◽  
Vol 7 (3) ◽  
pp. 229
Author(s):  
Bettina Volford ◽  
Mónika Varga ◽  
András Szekeres ◽  
Alexandra Kotogán ◽  
Gábor Nagy ◽  
...  
Keyword(s):  
Wheat Bran ◽  
Enzyme Production ◽  
Specific Activity ◽  
Prebiotic Synthesis ◽  
Crude Enzyme ◽  
Oligosaccharide Synthesis ◽  
Industrial Enzymes ◽  
Chromogenic Agar ◽  
Lichtheimia Ramosa ◽  
Excellent Source

β-Galactosidases of Mucoromycota are rarely studied, although this group of filamentous fungi is an excellent source of many industrial enzymes. In this study, 99 isolates from the genera Lichtheimia, Mortierella, Mucor, Rhizomucor, Rhizopus and Umbelopsis, were screened for their β-galactosidase activity using a chromogenic agar approach. Ten isolates from the best producers were selected, and the activity was further investigated in submerged (SmF) and solid-state (SSF) fermentation systems containing lactose and/or wheat bran substrates as enzyme production inducers. Wheat bran proved to be efficient for the enzyme production under both SmF and SSF conditions, giving maximum specific activity yields from 32 to 12,064 U/mg protein and from 783 to 22,720 U/mg protein, respectively. Oligosaccharide synthesis tests revealed the suitability of crude β-galactosidases from Lichtheimia ramosa Szeged Microbiological Collection (SZMC) 11360 and Rhizomucor pusillus SZMC 11025 to catalyze transgalactosylation reactions. In addition, the crude enzyme extracts had transfructosylation activity, resulting in the formation of fructo-oligosaccharide molecules in a sucrose-containing environment. The maximal oligosaccharide concentration varied between 0.0158 and 2.236 g/L depending on the crude enzyme and the initial material. Some oligosaccharide-enriched mixtures supported the growth of probiotics, indicating the potential of the studied enzyme extracts in future prebiotic synthesis processes.

Impact of wheat bran micronization on dough properties and bread quality: Part I – Bran functionality and dough properties

2021 ◽  
Vol 353 ◽  
pp. 129407
Author(s):  
Suyun Lin ◽  
Xiaoxuan Jin ◽  
Jing Gao ◽  
Ziyou Qiu ◽  
Jian Ying ◽  
...  
Keyword(s):  
Wheat Bran ◽  
Bread Quality ◽  
Dough Properties
Sign in / Sign up

Export Citation Format

Share Document