Influence of Mean Stress on the Fatigue Behavior of 304L SS in Air and PWR Water

Author(s):  
H. D. Solomon ◽  
C. Amzallag ◽  
A. J. Vallee ◽  
R. E. De Lair

Load-controlled experiments on 304L stainless steel were run in Air and PWR water, at 150°C and 300°C, with and without a mean stress of 100MPa. These experiments were run to determine the influence of temperature, environment, and mean stress on the 107 Cycle Fatigue Limit stress amplitude. A 100MPa mean stress was found to have different effects at the different temperatures and environments. In contrast to all the conventional models used to describe the effects of mean stress, when the testing was done at 300°C (for both air and PWR water), a 100MPa mean stress was found to raise the 107 Cycle Fatigue Limit relative to that observed without a mean stress. This was ascribed to the effect of the hardening due to the initial straining and to secondary hardening, both of which are more pronounced at 300°C than at 150°C. The increased initial and secondary hardening resulted in the development of less non-elastic strain, thereby improving the fatigue behavior. In PWR water at 150°C, a 100MPa mean stress reduced the 107 Cycle Fatigue Limit by more than that predicted by conventional mean stress models, but in air at 150°C, the decrease in the endurance limit was more in keeping with the predictions of these models. This difference was ascribed to the effect of the PWR water, in the absence of significant initial straining and secondary hardening.

2012 ◽  
Vol 06 ◽  
pp. 251-256
Author(s):  
HO-YOUNG YANG ◽  
JAE-HOON KIM ◽  
KEUN-BONG YOO

Co -base superalloys have been applied in the stationary components of gas turbine owing to their excellent high temperature properties. Low cycle fatigue data on ECY-768 reported in a companion paper were used to evaluate fatigue life prediction models. In this study, low cycle fatigue tests are performed as the variables of total strain range and temperatures. The relations between plastic and total strain energy densities and number of cycles to failure are examined in order to predict the low cycle fatigue life of Cobalt-based super alloy at different temperatures. The fatigue lives is evaluated using predicted by Coffin-Manson method and strain energy methods is compared with the measured fatigue lives at different temperatures. The microstructure observing was performed for how affect able to low-cycle fatigue life by increasing the temperature.


2006 ◽  
Vol 306-308 ◽  
pp. 151-156
Author(s):  
Priyo Tri Iswanto ◽  
Shinichi Nishida ◽  
Nobusuke Hattori ◽  
Yuji Kawakami

In order to study the effect of plastic deformation on fatigue behaviors of plastically deformed specimen, bending fatigue tests had been performed on notched deformed stainless steel specimens. Also pulsating fatigue tests were done on notched non-deformed specimens to evaluate the influence of mean stress on fatigue behavior of notched non-deformed specimens. The result showed that according to increase of deformation value, the fatigue limits of these specimens also significantly increase. Fatigue limit of rolled specimen does not linearly increase with increase in plastic deformation value. Based on fatigue limit diagram, the effect of compressive residual stress on fatigue limit improvement of stainless steel is higher than that of work-hardening. In case of non-deformed specimen, when the compressive mean stress increases, the fatigue limit and the number of cycles to failure increase. In case of tensile mean stress, this kind of mean stress decreases the fatigue limit.


2019 ◽  
Vol 6 (9) ◽  
pp. 0965a6 ◽  
Author(s):  
Dhananjay Pradhan ◽  
G S Mahobia ◽  
K Chattopadhyay ◽  
D C Fernando ◽  
N Paulose ◽  
...  

Author(s):  
M. Shafiqur Rahman ◽  
Uttam K. Chakravarty

Abstract The tensile and fatigue properties of laser-powder-bed-fusion (L-PBF) processed Ti-6Al-4V specimens are investigated at different loading conditions. Two types of as-built and post-machined L-PBF processed dogbone specimens are considered for the study, one is an ASTME8M round specimen and the other one is a customized small-scale flat structure. The tensile and fatigue behavior of the specimens are investigated numerically using the finite element (FE) method. The FE modeling considers both low cycle fatigue (LCF) and high cycle fatigue (HCF) test conditions by applying cyclic loads in fully-reversed and stress ratio R = 0.1 conditions. The FE results for the von Mises stress, strain, total deformation, fatigue life, factor of safety, and fatigue limit of the Ti-6Al-4V specimens are obtained at room temperature (295 K). Results obtained from the model show that the fatigue life decreases as the load increases. It is also found that fatigue life does not vary with the change of the test frequency under a specific fatigue load. The comparison of mechanical properties of the L-PBF processed specimens with conventionally manufactured Ti-6Al-4V parts is also shown to understand the differences in the tensile and fatigue behavior. The validation of the FE model is performed by comparing the numerical results for the yield stress and fatigue limit with the experimental results found from the literature. The overall study contains a detailed analysis of the tensile and fatigue behavior of additively manufactured Ti-6Al-4V parts and provides a guide to investigating the similar properties for other functional materials used in the L-PBF process.


Author(s):  
Yoshiaki Matsumori ◽  
Jumpei Nemoto ◽  
Yuji Ichikawa ◽  
Isamu Nonaka ◽  
Hideo Miura

Since high-cycle fatigue loads is applied to the pipes in various energy and chemical plants due to the vibration and frequent temperature change of fluid in the pipes, the high-cycle fatigue behavior of the alloys used for pipes should be understood quantitatively in the structural reliability design of the pipes. The purpose of this study, therefore, is to clarify the high-cycle fatigue strength and fracture mechanism of the modified 9Cr-1Mo steel at temperatures higher than 400°C. This material is one of the effective candidates for the pipes in fast breeder demonstration reactor systems. A rotating bending fatigue test was applied to samples at 50 Hz in air. The stress waveform was sinusoidal and the stress ratio was fixed at −1. The fatigue limit was observed at room temperature and it was about 420 MPa. This value was lower than the 0.2% proof stress of this alloy by about 60 MPa. This decrease can be attributed to the cyclic softening of this material. The limited cycles at knee point was about 8×105 cycles. All fracture was initiated from a single surface crack and no inclusion-induced fracture was observed in the fracture surface by SEM. Thus, the high-cycle fatigue design based on the fatigue limit may be applicable to the modified 9Cr-1Mo steel at room temperature. The fatigue limit of about 350 MPa was also observed at 400°C, and it appeared at about 107 cycles, while it appeared at around 106 cycles at room temperature. Thus, it was confirmed that the fatigue strength of this alloy decrease with temperature. However, the fatigue limit didn’t appear at 550°C up to 108 cycles. The fatigue limit may disappear in this alloy at 550°C. It is very important, therefore, to evaluate the ultra-high cycle fatigue strength of this alloy at temperatures higher than 400°C.


Sign in / Sign up

Export Citation Format

Share Document