Nitrogen Removal in a Phase-Separated Up-Flow Anaerobic Sludge Blanket Reactor Combined with Biological Nutrient Removal

2009 ◽  
Vol 26 (2) ◽  
pp. 397-406 ◽  
Author(s):  
Sang Min Park ◽  
Noh Back Park ◽  
Tae Kyeong Seo ◽  
Hang Bae Jun
Keyword(s):  
Nitrogen Removal ◽  
Nutrient Removal ◽  
Biological Nutrient Removal ◽  
Anaerobic Sludge ◽  
Anaerobic Sludge Blanket

scholarly journals Biological Nutrient Removal Model No. 2 (BNRM2): a general model for wastewater treatment plants

2013 ◽  
Vol 67 (7) ◽  
pp. 1481-1489 ◽  
Author(s):  
R. Barat ◽  
J. Serralta ◽  
M. V. Ruano ◽  
E. Jiménez ◽  
J. Ribes ◽  
...  
Keyword(s):  
Wastewater Treatment ◽  
Nitrogen Removal ◽  
Nutrient Removal ◽  
Wastewater Treatment Plants ◽  
Treatment Plant ◽  
Operating Conditions ◽  
Plant Performance ◽  
Biological Nutrient Removal ◽  
Nitrite Oxidizing Bacteria ◽  
Removal Model

This paper presents the plant-wide model Biological Nutrient Removal Model No. 2 (BNRM2). Since nitrite was not considered in the BNRM1, and this previous model also failed to accurately simulate the anaerobic digestion because precipitation processes were not considered, an extension of BNRM1 has been developed. This extension comprises all the components and processes required to simulate nitrogen removal via nitrite and the formation of the solids most likely to precipitate in anaerobic digesters. The solids considered in BNRM2 are: struvite, amorphous calcium phosphate, hidroxyapatite, newberite, vivianite, strengite, variscite, and calcium carbonate. With regard to nitrogen removal via nitrite, apart from nitrite oxidizing bacteria two groups of ammonium oxidizing organisms (AOO) have been considered since different sets of kinetic parameters have been reported for the AOO present in activated sludge systems and SHARON (Single reactor system for High activity Ammonium Removal Over Nitrite) reactors. Due to the new processes considered, BNRM2 allows an accurate prediction of wastewater treatment plant performance in wider environmental and operating conditions.

scholarly journals Anammox biofilm process using sugarcane bagasse as an organic carrier

2021 ◽  
Vol 26 (1) ◽  
pp. 25
Author(s):  
Zulkarnaini Zulkarnaini ◽  
Puti Sri Komala ◽  
Arief Almi
Keyword(s):  
Sugarcane Bagasse ◽  
Nitrogen Removal ◽  
Removal Rate ◽  
Nitrogen Loading ◽  
Uasb Reactor ◽  
Anaerobic Sludge ◽  
Ammonium Oxidation ◽  
Biofilm Process ◽  
Anaerobic Sludge Blanket ◽  
Anammox Process

The anaerobic ammonium oxidation (anammox) biofilm process commonly uses various inorganic carriers to enhance nitrogen removal under anaerobic conditions. This study aims to analyze the performance of nitrogen removal in anammox process using sugarcane bagasse as an organic carrier. The experiment was carried out by using an up‐flow anaerobic sludge blanket (UASB) reactor for treating artificial wastewater at room temperature. The reactor was fed with ammonium and nitrite with the concentrations of 70‐150 mg–N/L and variations in the hydraulic retention time of 24 and 12 h. The granular anammox belongs to the genus Candidatus Brocadia sinica that was added as an inoculum of the reactor operation. The experimental stoichiometric of anammox for ΔNO2‐–N: ΔNH4+–N and ΔNO3‐: ΔNH4+ were 1.24 and 0.18, respectively, which is similar to anammox stoichiometry. The maximum Nitrogen Removal Rate (NRR) has achieved 0.29 kg–N/m3.d at Nitrogen Loading Rate (NLR) 0.6 kg–N/m3.d. The highest ammonium conversion efficiency (ACE) and nitrogen removal efficiency (NRE) were 88% and 85%, respectively. Based on this results, it indicated that sugarcane bagasse as organic carriers could increase the amount of total nitrogen removal by provided of denitrification process but inhibited the anammox process at a certain COD concentration.

Performance and inhibition recovery of anammox reactors seeded with different types of sludge

2011 ◽  
Vol 63 (4) ◽  
pp. 710-718 ◽  
Author(s):  
S. Q. Ni ◽  
J. Meng
Keyword(s):  
Nitrogen Removal ◽  
Granular Sludge ◽  
Recovery Process ◽  
Nitrogen Loading ◽  
Anaerobic Sludge ◽  
Anammox Bacteria ◽  
Recovery Processes ◽  
Anammox Activity ◽  
Different Types ◽  
Anaerobic Sludge Blanket

In order to study the performance, inhibition and recovery processes of different types of anammox sludge, three up-flow anaerobic sludge blanket reactors were inoculated with flocculent sludge, granular sludge, and cultured inactive methanogenic granules. During stable period, with nitrogen loading rates of 0.9–1.1 kg/m3/d, the total nitrogen removal efficiencies of these reactors averaged at 86.5%, 90.8% and 93.5%, respectively. The kinetics study indicated that the reactor seeded with cultured inactive methanogenic granules possessed the highest nitrogen removal potential, followed by the granular anammox reactor and the flocculent anammox reactor. The study suggested that a concentration as high as 988.3 mg NH4+-N/L and 484.4 mg NO2−-N/L could totally inhibit granular anammox bacteria and result in a inhibition of 50% flocculent anammox activity. In addition, reactors seeded with flocculent sludge and anammox granules could be fully recovered by decreasing their influent substrate concentrations. However, the decrease of influent substrate concentration for the reactor with cultured inactive methanogenic granules could only restore about 75% of its bacterial activity. In this study, anammox bacteria purity was the major factor to evaluate the recovery ability in comparison with sludge type. Free ammonia was a more appropriate indicator for the anammox recovery process compared to free nitric acid.

High nitrogen removal rate using ANAMMOX process at short hydraulic retention time

2013 ◽  
Vol 67 (5) ◽  
pp. 968-975 ◽  
Author(s):  
C. G. Casagrande ◽  
A. Kunz ◽  
M. C. De Prá ◽  
C. R. Bressan ◽  
H. M. Soares
Keyword(s):  
Nitrogen Removal ◽  
Removal Rate ◽  
Uasb Reactor ◽  
Anaerobic Sludge ◽  
Ammonium Oxidation ◽  
High Nitrogen ◽  
Total N ◽  
Column Reactor ◽  
Anaerobic Sludge Blanket ◽  
Anammox Process

The anaerobic ammonium oxidation (ANAMMOX) is a chemolithoautotrophic process, which converts NH4+ to N2 using nitrite (NO2−) as the electron acceptor. This process has very high nitrogen removal rates (NRRs) and is an alternative to classical nitrification/denitrification wastewater treatment. In the present work, a strategy for nitrogen removal using ANAMMOX process was tested evaluating their performance when submitted to high loading rates and very short hydraulic retention times (HRTs). An up-flow ANAMMOX column reactor was inoculated with 30% biomass (v v−1) fed from 100 to 200 mg L−1 of total N (NO2−-N + NH4+-N) at 35 °C. After start-up and process stability the maximum NRR in the up-flow anaerobic sludge blanket (UASB) reactor was 18.3 g-N L−1 d−1 operated at 0.2 h of HRT. FISH (fluorescence in situ hybridization) analysis and process stoichiometry confirmed that ANAMMOX was the prevalent process for nitrogen removal during the experiments. The results point out that high NRRs can be obtained at very short HRTs using up-flow ANAMMOX column reactor configuration.

Importance of the ammonia volatilization rates in shallow maturation ponds treating UASB reactor effluent

2012 ◽  
Vol 66 (6) ◽  
pp. 1239-1246 ◽  
Author(s):  
Fernando Augusto Lopes de Assunção ◽  
Marcos von Sperling
Keyword(s):  
Nitrogen Removal ◽  
Ammonia Volatilization ◽  
Ammonia Nitrogen ◽  
Upflow Anaerobic Sludge Blanket ◽  
Uasb Reactor ◽  
Anaerobic Sludge ◽  
Unit Surface Area ◽  
In Series ◽  
Belo Horizonte ◽  
Anaerobic Sludge Blanket

This study aimed at determining the influence of ammonia volatilization on nitrogen removal in polishing (maturation) ponds treating sanitary effluent from upflow anaerobic sludge blanket (UASB) reactors in the city of Belo Horizonte, Brazil. An apparatus for the capture and absorption of volatilized ammonia in three polishing ponds in series was installed. Volatilized ammonia was captured by a chamber on the surface of the ponds and dissolved in boric acid solution, in order to estimate the amount of ammonia per unit surface area of each pond. Low rates of volatilization, below 0.2 kg/ha.d, in about 75% of samples from all the ponds, were observed. The mass balance of ammonia nitrogen of the ponds showed that the volatilization represented only about 2% of the total removal of nitrogen from the polishing ponds. The results obtained suggest that ammonia volatilization was a mechanism of little importance in nitrogen removal in the investigated polishing ponds.

scholarly journals Biological nutrient removal in a continuous biofilm process

2017 ◽  
Vol 12 (4) ◽  
pp. 797-805 ◽  
Author(s):  
T. Saltnes ◽  
G. Sørensen ◽  
S. Eikås
Keyword(s):  
Nitrogen Removal ◽  
Nutrient Removal ◽  
Laboratory Experiments ◽  
Continuous Process ◽  
Biological Nutrient Removal ◽  
Simultaneous Nitrification And Denitrification ◽  
Organic Substances ◽  
Phosphorous Removal ◽  
Improved Performance ◽  
Biofilm Process

Abstract A new biological phosphorous and nitrogen removal process is developed. The process is based on biofilm on carrier elements with enhanced biological phosphorous removal and simultaneous nitrification and denitrification in a continuous process. Results from 3 years of pilot and laboratory experiments are presented with regards to removal of organic substances, phosphorous and nitrogen. This process demonstrates essential benefits and improved performance compared to other EBPR-processes in operation today. The first full scale plant was put in operation in May 2016 at Hias WWTP in Norway.

Sludge production based on organic matter and nitrogen removal performances

2011 ◽  
Vol 6 (2) ◽  
Author(s):  
N. Serón ◽  
S. Puig ◽  
S.C.F. Meijer ◽  
M.D. Balaguer ◽  
J. Colprim
Keyword(s):  
Organic Matter ◽  
Nitrogen Removal ◽  
Nutrient Removal ◽  
Biological Treatment ◽  
Wastewater Treatment Plants ◽  
The Other ◽  
Biological Nutrient Removal ◽  
Optimal Conditions ◽  
Urban Wastewater ◽  
Sludge Production

Excess biomass produced during the biological treatment of wastewater requires costly disposal. As environmental and legislative constraints increase, there is considerable impetus for reducing the sludge production. Nowadays, several strategies for minimizing it production are applied but high costs still limit their application in full-scale wastewater treatment plants (WWTPs). On the other hand, biological nutrient removal (BNR) process may have an impact on the sludge production. This paper deals with the effect on the organic matter and nitrogen performances on the sludge production treating urban wastewater. The results demonstrated that the sewage sludge production was reduced between 50 to 60% (0.38 to 0.16 kg VSS·kg−1 COD) while improving the nitrogen removal efficiency from 33% to 79%. Therefore, an efficient way to minimize the sludge production, it is by operating the WWTP in optimal conditions for nutrient removal.

scholarly journals Aplikasi Proses Anammox Dalam Penyisihan Nitrogen Menggunakan Reaktor Up-Flow Anaerobic Sludge Blanket

2020 ◽  
Vol 21 (1) ◽  
pp. 31-39
Author(s):  
Zulkarnaini Zulkarnaini ◽  
Reri Afrianita ◽  
Ilham Hagi Putra
Keyword(s):  
Nitrogen Removal ◽  
Nitrogen Loading ◽  
Laboratory Scale ◽  
Uasb Reactor ◽  
Anaerobic Sludge ◽  
Anammox Bacteria ◽  
Stable Operation ◽  
Start Up ◽  
Anaerobic Sludge Blanket ◽  
Anammox Process

ABSTRACTAnammox process is a more practical alternative in biological nitrogen removal compared to conventional nitrification-denitrification processes. This process conducted at the optimum temperature of 370C. Indonesia, as a tropical country, has the potential for the application of anammox processes to remove nitrogen in wastewater. The purpose of this study was to analyze the efficiency of nitrogen removal in the anammox process using the Up-Flow Anaerobic Sludge Blanket (UASB) reactor at ambient temperature with variations in the hydraulic retention time (HRT) of 24 hours and 12 hours, at the laboratory scale. Samples are measured twice a week using a UV-Vis spectrophotometer. As a seeding sludge for start-up, the reactor was inoculated with granular anammox bacteria genus Candidatus Brocadia. At the stable operation, the ratio of ΔNO2--N:ΔNH4+-N and ΔNO3--N:ΔNH4+-N approach the stoichiometry of the anammox process were 1.20 and 0.21, respectively. The performance of nitrogen removal with 24-hour HRT obtained a maximum nitrogen removal rate (NRR) of 0.113 kg-N/m3.d with nitrogen loading rate (NLR) 0.14 kg-N/m3.d, and at 12-hour HRT, maximum NRR  of 0.196 kg-N/m3.d with NLR 0,28 kg-N/m3.d. Ammonium Conversion Efficiency (ACE) and Nitrogen Removal Efficiency (NRE) maximum for HRT 24 hours were 82% and 77%, respectively while HRT 12 hours were 72% and 68%, respectively. The anammox process operated stably in the tropical temperature with a temperature range of 23-280C on a laboratory scale using the UASB reactor.Keywords: anammox, nitrogen, temperature, tropical, uasb.ABSTRAKProses anammox menjadi alternatif yang lebih efektif dalam penyisihan nitrogen secara biologi dibandingkan dengan proses konvensional nitrifikasi-denitrifikasi. Proses ini berlangsung optimum pada suhu 370C. Indonesia sebagai negara tropis memiliki potensi untuk aplikasi proses anammox untuk menghilangkan nitrogen pada air limbah. Penelitian ini bertujuan untuk menganalisis efesiensi penyisihan nitrogen pada proses anammox menggunakan Up-Flow Anaerobic Sludge Blanket (UASB) reaktor pada suhu ambien dengan variasi Waktu Tinggal Hidrolik (WTH) 24 jam dan 12 jam, pada skala laboratorium. Sampel diukur dua kali setiap minggu menggunakan spektrofotometer UV-Vis. Sebagai seeding sludge (lumpur biakan) untuk start-up (memulai) reaktor digunakan bakteri anammox genus Candidatus Brocadia berbentuk granular. Berdasarkan hasil pengukuran, didapatkan nilai rasio ΔNO2--N:ΔNH4+-N dan ΔNO3--N:ΔNH4+-N mendekati stoikiometri proses anammox yaitu 1,20 dan 0,21. Kinerja penyisihan nitrogen dengan WTH 24 jam didapatkan nilai tingkat penyisihan nitrogen (TPyN ) maksimum 0,113 kg-N/m3.h pada tingkat pemuatan nitrogen (TPN) 0,14 kg-N/m3.h, dan WTH 12 jam nilai TPyN  maksimum 0,196 kg-N/m3.h pada TPN 0,28 kg-N/m3.h. Nilai efisiensi konversi amonia (EKA) dan efisiensi penyisihan nitrogen (EPN) maksimum pada WTH 24 jam berturut-turut adalah 82% dan 77%, sedangkan pada WTH 12 jam berturut-turut adalah 72% dan 68%. Penelitian membuktikan bahwa proses anammox dapat berlangsung stabil pada daerah tropis dengan suhu terukur 21-290C pada skala laboratorium menggunakan UASB reaktor. Kata kunci: Anammox, nitrogen, temperatur, tropis, uasb.

Sign in / Sign up

Export Citation Format

Share Document