Highly conducting p-type nanocrystalline silicon thin films preparation without additional hydrogen dilution

2018 ◽  
Author(s):  
Chandralina Patra ◽  
Debajyoti Das
Keyword(s):  
Thin Films ◽  
Nanocrystalline Silicon ◽  
Silicon Thin Films ◽  
Hydrogen Dilution ◽  
P Type ◽  
Additional Hydrogen

Optimization of p-type Nanocrystalline Silicon Thin Films for Solar Cells and Photodiodes

2009 ◽  
Vol 1153 ◽  
Author(s):  
Yuri Vygranenko ◽  
Ehsanollah Fathi ◽  
Andrei Sazonov ◽  
Manuela Vieira ◽  
Gregory Heiler ◽  
...  
Keyword(s):  
Thin Films ◽  
Film Thickness ◽  
Chemical Vapor ◽  
Percolation Cluster ◽  
Nanocrystalline Silicon ◽  
Film Structure ◽  
Silicon Thin Films ◽  
Low Leakage ◽  
In Doping ◽  
P Type

AbstractWe report on structural, electronic, and optical properties of boron-doped, hydrogenated nanocrystalline silicon (nc-Si:H) thin films deposited by plasma-enhanced chemical vapor deposition (PECVD) at a substrate temperature of 150°C. Film properties were studied as a function of trimethylboron-to-silane ratio and film thickness. The film thickness was varied in the range from 14 to 100 nm. The conductivity of 60 nm thick films reached a peak value of 0.07 S/cm at a doping ratio of 1%. As a result of amorphization of the film structure, which was indicated by Raman spectra measurements, any further increase in doping reduced conductivity. We also observed an abrupt increase in conductivity with increasing film thickness ascribed to a percolation cluster composed of silicon nanocrystallites. The absorption loss of 25% at a wavelength of 400 nm was measured for the films with optimized conductivity deposited on glass and glass/ZnO:Al substrates. A low-leakage, blue-enhanced p-i-n photodiode with an nc-Si p-layer was also fabricated and characterized.

¼c Silicon Thin Films Deposited by Remote Plasma Enhanced Chemical Vapor Deposition Process

1990 ◽  
Vol 192 ◽  
Author(s):  
C. Wang ◽  
G. N. Parsons ◽  
S. S. Kim ◽  
E. C. Buehler ◽  
R. J. Nemanich ◽  
...  
Keyword(s):  
Thin Films ◽  
Chemical Vapor ◽  
Deposition Process ◽  
Substrate Material ◽  
Degree Of Crystallinity ◽  
Silicon Thin Films ◽  
Hydrogen Dilution ◽  
Type C ◽  
Si Films ◽  
P Type

ABSTRACTIn an earlier study, we deposited ¼c-Si thin films by reactive magnetron sputtering (RMS). Here we extend our studies to the deposition of both undoped and high conductivity N-type and P-type ¼c-Si thin films by a remote PECVD. We show that ¼c-Si films can be deposited by bringing hydrogen, H2, into the source gas mixtures. The H2 could introduced by either upstream in a He/H2 mixture and directly plasma excited, or downstream, and be remotely excited along with the silane, SiH4, feed gas. The degree of crystallinity is shown to depend on the hydrogen dilution, the substrate temperature and the substrate material.

Influence of Substrate Temperature and Hydrogen Dilution Ratio on the Properties of Nanocrystalline Silicon Thin Films Grown by Hot-Wire Chemical Vapor Deposition

2003 ◽  
Vol 762 ◽  
Author(s):  
H.R. Moutinho ◽  
C.-S. Jiang ◽  
B. Nelson ◽  
Y. Xu ◽  
J. Perkins ◽  
...  
Keyword(s):  
Thin Films ◽  
Substrate Temperature ◽  
Seed Layer ◽  
Chemical Vapor ◽  
Nanocrystalline Silicon ◽  
Dilution Ratio ◽  
Crystal Silicon ◽  
Silicon Thin Films ◽  
Hydrogen Dilution ◽  
Influence Of Substrate

AbstractWe have studied the influence of substrate temperature and hydrogen dilution ratio on the properties of silicon thin films deposited on single-crystal silicon and glass substrates. We varied the initial substrate temperature from 200° to 400°C and the dilution ratio from 10 to 100. We also studied the effectiveness of the use of a seed layer to increase the crystallinity of the films. The films were analyzed by atomic force microscopy, X-ray diffraction, Raman spectroscopy, and transmission and scanning electron microscopy. We found that as the dilution ratio is increased, the films go from amorphous, to a mixture of amorphous and crystalline, to nanocrystalline. The effect of substrate temperature is to increase the amount of crystallinity in the film for a given dilution ratio. We found that the use of a seed layer has limited effects and is important only for low values of dilution ratio and substrate temperature, when the films have large amounts of the amorphous phase.

Effects of high hydrogen dilution ratio on optical properties of hydrogenated nanocrystalline silicon thin films

2011 ◽  
Vol 257 (23) ◽  
pp. 9840-9845 ◽  
Author(s):  
Liqiang Guo ◽  
Jianning Ding ◽  
Jichang Yang ◽  
Guanggui Cheng ◽  
Zhiyong Ling ◽  
...  
Keyword(s):  
Thin Films ◽  
Optical Properties ◽  
Nanocrystalline Silicon ◽  
Dilution Ratio ◽  
High Hydrogen ◽  
Silicon Thin Films ◽  
Hydrogen Dilution

Giant Anisotropy of Conductivity in Hydrogenated Nanocrystalline Silicon Thin Films

1998 ◽  
Vol 536 ◽  
Author(s):  
A. B. Pevtsov ◽  
N. A. Feoktistov ◽  
V. G. Golubev
Keyword(s):  
Thin Films ◽  
Film Thickness ◽  
Percolation Theory ◽  
Nanocrystalline Silicon ◽  
Spatial Light Modulators ◽  
Light Emitting ◽  
Light Modulators ◽  
Silicon Thin Films ◽  
Longitudinal Conductivity ◽  
Transverse Conductivity

AbstractThin (<1000 Å) hydrogenated nanocrystalline silicon films are widely used in solar cells, light emitting diodes, and spatial light modulators. In this work the conductivity of doped and undoped amorphous-nanocrystalline silicon thin films is studied as a function of film thickness: a giant anisotropy of conductivity is established. The longitudinal conductivity decreases dramatically (by a factor of 109 − 1010) as the layer thickness is reduced from 1500 Å to 200 Å, while the transverse conductivity remains close to that of a doped a- Si:H. The data obtained are interpreted in terms of the percolation theory.

Sign in / Sign up

Export Citation Format

Share Document