Pressure-Induced Denaturation of β-Lactoglobulin in Skim Milk: Effect of Milk Concentration

2012 ◽  
Vol 60 (26) ◽  
pp. 6565-6570 ◽  
Author(s):  
Skelte G. Anema
Keyword(s):  
Skim Milk ◽  
Β Lactoglobulin

scholarly journals Transmission of Major and Minor Serum Proteins during Microfiltration of Skim Milk: Effects of Pore Diameters, Concentration Factors and Processing Stages

Foods ◽  
2021 ◽  
Vol 10 (4) ◽  
pp. 888
Author(s):  
Zhibin Li ◽  
Dasong Liu ◽  
Shu Xu ◽  
Wenjin Zhang ◽  
Peng Zhou
Keyword(s):  
Serum Proteins ◽  
Skim Milk ◽  
Transmembrane Pressure ◽  
Recovery Yield ◽  
Membrane Flux ◽  
Crossflow Velocity ◽  
Inner Diameter ◽  
Concentration Factors ◽  
20 Nm ◽  
Β Lactoglobulin

Effects of pore diameters (100, 50, and 20 nm), concentration factors (1–8) and processing stages (1–5) on the transmission of major serum proteins (β-lactoglobulin and α-lactalbumin) and minor serum proteins (immunoglobulin (Ig) G, IgA, IgM, lactoferrin (LF), lactoperoxidase (LPO), xanthine oxidase (XO)) during ceramic microfiltration (MF) of skim milk were studied. Holstein skim milk was microfiltered at a temperature of 50 °C, a transmembrane pressure of 110 kPa and a crossflow velocity of 6.7 m/s, using a tubular single stainless steel module that consisted of three ceramic tubes, each with 19 channels (3.5 mm inner diameter) and a length of 0.5 m. For MF with 100 nm and 50 nm pore diameters, the recovery yield of major serum proteins in permeate was 44.3% and 44.1%, while the recovery yield of minor serum proteins was slightly less by 0%–8% than 50 nm MF. MF with 20 nm pore diameters showed a markedly lower (by 12%–45%) recovery yield for both major and minor serum proteins, corresponding with its lower membrane flux. Flux sharply decreased with an increasing concentration factor (CF) up to four, and thereafter remained almost unchanged. Compared to the decrease (88%) of flux, the transmission of major and minor serum proteins was decreased by 4%–15% from CF = one to CF = eight. With increasing processing stages, the flux gradually increased, and the recovery yield of both major and minor proteins in the permeate gradually decreased and reached a considerably low value at stage five. After four stages of MF with 100 nm pore diameter and a CF of four for each stage, the cumulative recovery yield of major serum proteins, IgG, IgA, IgM, LF, LPO, and XO reached 95.7%, 90.8%, 68.5%, 34.1%, 15.3%, 39.1% and 81.2% respectively.

scholarly journals Development and Validation of a Method for the Quantification of Milk Proteins in Food Products Based on Liquid Chromatography with Mass Spectrometric Detection

2011 ◽  
Vol 94 (4) ◽  
pp. 1043-1059 ◽  
Author(s):  
Petra Lutter ◽  
Véronique Parisod ◽  
Hans Weymuth
Keyword(s):  
Milk Powder ◽  
Skim Milk ◽  
Internal Standard ◽  
Milk Proteins ◽  
Skim Milk Powder ◽  
Selected Reaction Monitoring ◽  
Validation Data ◽  
Development And Validation ◽  
Protein Rich ◽  
Β Lactoglobulin

Abstract The protection of allergic consumers is crucial to the food industry. Therefore, accurate methods for the detection of food allergens are required. Targeted detection of selected molecules by MS combines high selectivity with accurate quantifcation. A confrmatory method based on LC/selected reaction monitoring (SRM)-MS/MS was established and validated for the quantifcation of milk traces in food. Tryptic peptides of the major milk proteins β-lactoglobulin, β-casein, αS2-casein, and κ-casein were selected as quantitative markers. Precise quantifcation was achieved using internal standard peptides containing isotopically labeled amino acids. For each peptide, qualifer and quantifer fragments were selected according to Commission Decision 2002/657/EC. A simple sample preparation method was established without immunoaffnity or SPE enrichment steps for food matrixes containing different amounts of protein, such as baby food, breakfast cereals, infant formula, and cereals. Intermediate reproducibility, repeatability, accuracy, and measurement uncertainty were determined for each matrix. LOD values of 0.2–0.5 mg/kg, e.g., for β-lactoglobulin, were comparable to those obtained with ELISA kits. An LOQ of approximately 5 mg/kg, expressed as mass fraction skim milk powder, was validated in protein-rich infant cereals. The obtained validation data show that the described LC/SRM-MS/MS approach can serve as a confrmatory method for the determination of milk traces in selected food matrixes.

scholarly journals Influence of Processing Temperature on Membrane Performance and Characteristics of Process Streams Generated during Ultrafiltration of Skim Milk

Foods ◽  
2020 ◽  
Vol 9 (11) ◽  
pp. 1721
Author(s):  
Ritika Puri ◽  
Upendra Singh ◽  
James A. O’Mahony
Keyword(s):  
Inverse Relationship ◽  
Skim Milk ◽  
Biochemical Properties ◽  
Processing Temperature ◽  
Casein Micelle ◽  
Plasmin Activity ◽  
Membrane Performance ◽  
Flux Decline ◽  
Dairy Ingredients ◽  
Β Lactoglobulin

The effects of processing temperature on filtration performance and characteristics of retentates and permeates produced during ultrafiltration (UF) of skim milk at 5, 20, and 50 °C were investigated. The results indicate that despite higher flux at 50 °C, UF under these conditions resulted in greater fouling and rapid flux decline in comparison with 5 and 20 °C. The average casein micelle diameter was higher in retentate produced at 5 and 20 °C. The retentate analysed at 5 °C displayed higher viscosity and shear thinning behaviour as compared to retentate analysed at 20 and 50 °C. Greater permeation of calcium and phosphorus was observed at 5 and 20 °C in comparison with 50 °C, which was attributed to the inverse relationship between temperature and solubility of colloidal calcium phosphate. Permeation of α-lactalbumin was observed at all processing temperatures, with permeation of β-lactoglobulin also evident during UF at 50 °C. All UF retentates were shown to have plasmin activity, while lower activity was measured in retentate produced at 5 °C. The findings revealed that UF processing temperature influences the physicochemical, rheological, and biochemical properties of, and thereby govern the resulting quality and functionality of, retentate- and permeate-based dairy ingredients.

High-pressure treatment of milk: effects on casein micelle structure and on enzymic coagulation

2000 ◽  
Vol 67 (1) ◽  
pp. 31-42 ◽  
Author(s):  
ERIC C. NEEDS ◽  
ROBERT A. STENNING ◽  
ALISON L. GILL ◽  
VICTORIA FERRAGUT ◽  
GILLIAN T. RICH
Keyword(s):  
Whey Proteins ◽  
Skim Milk ◽  
Casein Micelle ◽  
Casein Micelles ◽  
Dense Networks ◽  
Protein Levels ◽  
Micelle Structure ◽  
Milk Casein ◽  
Β Lactoglobulin ◽  
Gel Network

High isostatic pressures up to 600 MPa were applied to samples of skim milk before addition of rennet and preparation of cheese curds. Electron microscopy revealed the structure of rennet gels produced from pressure-treated milks. These contained dense networks of fine strands, which were continuous over much bigger distances than in gels produced from untreated milk, where the strands were coarser with large interstitial spaces. Alterations in gel network structure gave rise to differences in rheology with much higher values for the storage moduli in the pressure-treated milk gels. The rate of gel formation and the water retention within the gel matrix were also affected by the processing of the milk. Casein micelles were disrupted by pressure and disruption appeared to be complete at treatments of 400 MPa and above. Whey proteins, particularly β-lactoglobulin, were progressively denatured as increasing pressure was applied, and the denatured β-lactoglobulin was incorporated into the rennet gels. Pressure-treated micelles were coagulated rapidly by rennet, but the presence of denatured β-lactoglobulin interfered with the secondary aggregation phase and reduced the overall rate of coagulation. Syneresis from the curds was significantly reduced following treatment of the milk at 600 MPa, probably owing to the effects of a finer gel network and increased inclusion of whey protein. Levels of syneresis were more similar to control samples when the milk was treated at 400 MPa or less.

Heat-induced interactions of β-lactoglobulin and α-lactalbumin with the casein micelle in pH-adjusted skim milk

2000 ◽  
Vol 10 (8) ◽  
pp. 509-518 ◽  
Author(s):  
David J Oldfield ◽  
Harjinder Singh ◽  
Michael W Taylor ◽  
Kevin N Pearce
Keyword(s):  
Skim Milk ◽  
Casein Micelle ◽  
Β Lactoglobulin

Heat stability of milk

1980 ◽  
Vol 47 (2) ◽  
pp. 199-210 ◽  
Author(s):  
Donald F. Darling
Keyword(s):  
Temperature Dependence ◽  
Elevated Temperatures ◽  
Skim Milk ◽  
Heat Stability ◽  
Coagulation Time ◽  
Ph Values ◽  
Protein Polymerization ◽  
Casein Protein ◽  
Apparent Activation Energies ◽  
Β Lactoglobulin

SummaryThe heat stability of a standard reconstituted skim-milk preparation has been investigated as a function of pH, temperature of coagulation, and forewarming treatment. Apparent activation energies have been calculated from the temperature dependence of coagulation time, and a constant value of 144 kJ/mole has been found for milks between pH 6·6 and 6·9. The effect of forewarming resulted in a decrease in stability at the most acid pH values, a slight increase at higher pH but below the pH maximum, and a decrease in the region of the pH minimum. A working hypothesis is proposed for the mechanisms leading to the coagulation of milk at elevated temperatures, based upon Ca induced precipitation of casein, protein polymerization, β-lactoglobulin: κ-casein interaction, and precipitation of insoluble Ca phosphates.

Comparison of heat and pressure treatments of skim milk, fortified with whey protein concentrate, for set yogurt preparation: effects on milk proteins and gel structure

2000 ◽  
Vol 67 (3) ◽  
pp. 329-348 ◽  
Author(s):  
ERIC C. NEEDS ◽  
MARTA CAPELLAS ◽  
A. PATRICIA BLAND ◽  
PRETIMA MANOJ ◽  
DOUGLAS MACDOUGAL ◽  
...  
Keyword(s):  
Heat Treatment ◽  
Whey Protein ◽  
Skim Milk ◽  
Milk Proteins ◽  
Whey Protein Concentrate ◽  
Protein Concentrate ◽  
Casein Micelles ◽  
Micelle Structure ◽  
Dynamic Structures ◽  
Β Lactoglobulin

Heat (85 °C for 20 min) and pressure (600 MPa for 15 min) treatments were applied to skim milk fortified by addition of whey protein concentrate. Both treatments caused > 90% denaturation of β-lactoglobulin. During heat treatment this denaturation took place in the presence of intact casein micelles; during pressure treatment it occurred while the micelles were in a highly dissociated state. As a result micelle structure and the distribution of β-lactoglobulin were different in the two milks. Electron microscopy and immunolabelling techniques were used to examine the milks after processing and during their transition to yogurt gels. The disruption of micelles by high pressure caused a significant change in the appearance of the milk which was quantified by measurement of the colour values L*, a* and b*. Heat treatment also affected these characteristics. Casein micelles are dynamic structures, influenced by changes to their environment. This was clearly demonstrated by the transition from the clusters of small irregularly shaped micelle fragments present in cold pressure-treated milk to round, separate and compact micelles formed on warming the milk to 43 °C. The effect of this transition was observed as significant changes in the colour indicators. During yogurt gel formation, further changes in micelle structure, occurring in both pressure and heat-treated samples, resulted in a convergence of colour values. However, the microstructure of the gels and their rheological properties were very different. Pressure-treated milk yogurt had a much higher storage modulus but yielded more readily to large deformation than the heated milk yogurt. These changes in micelle structure during processing and yogurt preparation are discussed in terms of a recently published micelle model.

Improvement of rheological properties of firm acid gels by skim milk heating is conserved after stirring

2003 ◽  
Vol 70 (4) ◽  
pp. 423-431 ◽  
Author(s):  
P Cayot ◽  
J-F Fairise ◽  
B Colas ◽  
D Lorient ◽  
G Brulé
Keyword(s):  
Storage Modulus ◽  
Skim Milk ◽  
Rheological Parameters ◽  
Water Retention Capacity ◽  
Gel Structure ◽  
Casein Micelles ◽  
Retention Capacity ◽  
Β Lactoglobulin

The enhancement of the strength of set acid gels by heating milk was related to rheological parameters (water retention capacity, storage modulus) of corresponding stirred gels. To obtain accurate rheological data from stirred gel it was necessary to maintain a constant granulometry of gel particles and to recognize time after stirring as a contributing factor. Two hours after stirring, the gel exhibited a higher storage modulus when milk was heated above 80 °C. A measurement of viscosity of just-stirred yoghurt was sufficient to predict correctly the quality of a stirred gel analysed by viscoelastic measurements. Increased resstance to syneresis of just-stirred gels was related to higher viscosity. The quantity of β-lactoglobulin (β-lg) bound to casein micelles explains the improvement of these gel qualities. We have considered that the structure of the initial firm gel (mesostructure level) was conserved in fragments within the stirred gel. Consequently, the explanation given by various authors for the effect of heating milk on the properties of set gels can also be applied to stirred gels. The same mechanism, described in literature for structure formation of set gels from acidified milk is purposed to explain the role of heating milk on the recovery of gel structure after stirring. The β-lg association with casein micelles during heating favoured micelle connections during the acidification. It also favoured the association of gel fragments after stirring during the recovery in gel structure.

Sign in / Sign up

Export Citation Format

Share Document